2005 Ford F-350 sd problems
The Ford Super Duty (also known as the Ford F-Series Super Duty) is a series of heavy-duty pickup trucks produced by the Ford Motor Company since the 1999 model year. Slotted above the consumer-oriented Ford F-150, the Super Duty trucks are an expansion of the Ford F-Series range, from F-250 to the F-600. The F-250 through F-450 are offered as pickup trucks, while the F-350 through F-600 are offered as chassis cabs.
Rather than adapting the lighter-duty F-150 truck for heavier use, Super Duty trucks have been designed as a dedicated variant of the Ford F-Series. The heavier-duty chassis components allow for heavier payloads and towing capabilities. With a GVWR over 8,500 lb (3,900 kg), Super Duty pickups are Class 2 and 3 trucks, while chassis-cab trucks are offered in Classes 3, 4, 5, and 6. The model line also offers Ford Power Stroke V8 diesel engines as an option.
Ford also offers a medium-duty version of the F-Series (F-650 and F-750), which is sometimes branded as the Super Duty, but is another chassis variant. The Super Duty pickup truck also served as the basis for the Ford Excursion full-sized SUV.
The Super Duty trucks and chassis-cabs are assembled at the Kentucky Truck Plant in Louisville, Kentucky, and at Ohio Assembly in Avon Lake, Ohio. Prior to 2016, medium-duty trucks were assembled in Mexico under the Blue Diamond Truck joint venture with Navistar International.
Social links
Common 2005 Ford F-350 sd problems
The 2005 Ford F-350 Super Duty is a heavy-duty pickup truck that has been known for several common problems reported by its owners. This article will discuss some of these issues in detail.
- Exhaust Gas Recirculation (EGR) Valve Assembly Failure: The EGR valve assembly in the 2005 F-350 Super Duty has been reported to fail, causing issues with the vehicle's emissions and performance. The EGR valve is responsible for recirculating a portion of the exhaust gases back into the engine to reduce nitrogen oxide emissions. When it fails, it can cause the check engine light to illuminate, and the vehicle may experience a loss of power or poor fuel economy.
These are some of the common problems reported by owners of the 2005 Ford F-350 Super Duty. It is essential to address these issues promptly to ensure the safety and reliability of the vehicle. Regular maintenance and inspections can help identify potential problems before they become severe, and it is always recommended to consult with a certified mechanic or Ford dealership for any repairs or maintenance work.
Is a 2005 Ford f350 diesel a good truck?
Great shape and easy to drive
Not many 2005 Turbo Diesel SuperDutys out there with less mileage or look as good. The 8 ft. bed is ideal for towing if a 5th wheel is needed.
What does Ford SD mean?
The Ford Super Duty (also known as the Ford F-Series Super Duty) is a series of heavy-duty pickup trucks produced by the Ford Motor Company since the 1999 model year.
What is a Ford f350 SD?
2024 Ford F-350 Super Duty Review
This is the F-Series Super Duty truck to get when you need serious towing and hauling capability. An F-350 crew cab with four-wheel drive, the dual rear-wheel setup and the high-output diesel engine is rated to tow up to 28,000 pounds with a conventional trailer hitch, for example.
How many miles can a Ford f350 last?
The Ford F-350 Super Duty was iSeeCars' most durable model with 49.1% chance of reaching 250,000-plus miles. If when you roll off a dealership lot your goal is to hit at least a quarter of a million miles, Ford's F-350 Super Duty is the odds-on favorite to get you there, according to a report compiled by iSeeCars.
Is a 2005 Ford F350 diesel a good truck?
Great shape and easy to drive
Not many 2005 Turbo Diesel SuperDutys out there with less mileage or look as good. The 8 ft. bed is ideal for towing if a 5th wheel is needed.
What does F350 SD mean?
“Super Duty” is simply a way to distinguish these trucks from the base model in the Ford Series: the F-150. Not only that, but the bodywork and chassis are both different from the F-150 as well simply because these are bigger trucks.
What is the fuel economy of a 2005 Ford F350?
Based on data from 156 vehicles, 7,558 fuel-ups and 2,276,823 miles of driving, the 2005 Ford F-350 Super Duty gets a combined Avg MPG of 12.68 with a 0.08 MPG margin of error. Below you can see a distribution of the fuel-ups with 137 outliers (1.78%) removed.
How long do Ford F350 engines last?
200,000 miles
With proper care and regular maintenance, it's not uncommon for Ford F350 engines to last well beyond 200,000 miles. Routine oil changes, timely replacement of filters, and addressing any issues promptly can contribute to the longevity of the engine.
2005 Ford F-350 sd car problems categorized by type of issue
After analyzing all complaints sent to the NHTSA and researching popular Ford F-350 sd problems, we found that the most common problems with these 2023 model year vehicles are:
- Engine and engine cooling problems
- Steering problems
- Suspension problems
- Electrical system problems
- Fuel system problems
The graph below shows statistics for all 2005 Ford F-350 sd vehicle components and the number of complaints received.
Latest 25 complaints 2005 Ford F-350 sd
The NHTSA has received 217 complaints about various vehicle components related to the 2005 Ford F-350 sd. Below are the 25 most recent complaints reported for 2005 Ford F-350 sd vehicles.
2019-02-27
TIRES PROBLEM
- Date Of Incident: 2019-02-24
- VIN: 1FTWW31P95E
- Components: TIRES
- Summary: DRIVING ON INTERSTATE I-85 IN NORTH GA ON SUNDAY, FEBRUARY 24TH TRAVELING 65MPH. REAR DRIVER SIDE TIRE TREAD FLIES OFF. TRUCK ROCKS AND MAKES A LOT OF NOISE. ABLE TO MAINTAIN CONTROL OF VEHICLE AND MOVE TO EMERGENCY LANE. TIRE APPEARS TO HAVE PEELED APART LIKE A BANANA. *DT*JB
2018-09-02
STEERING PROBLEM
- Date Of Incident: 2018-08-31
- VIN: 1FTWW31P35E
- Components: STEERING
- Summary: DRIVING DOWN THE HIGHWAY I HIT A SMALL BUMP AT 65MPH AND THE ENTIRE FRONT END STARTED VIOLENTLY SHAKING LIKE IT WAS GOING TO FALL APART. HAS HAPPENED TO ME 3 TIMES NOW AND TO MY PREGNANT WIFE 3 TIMES IN ONE TRIP! VERY SCARY AND A SERIOUS ISSUE THAT SHOULD BE RECTIFIED IMMEDIATELY. EXTREMELY DANGEROUS SITUATION AT 60MPH+ OR ANY SPEED REALLY.
2017-07-18
ENGINE PROBLEM
- Date Of Incident: 2016-02-13
- Fire: 1
- VIN: 1FTWW33P75E
- Components: ENGINE
- Summary: 2005 FORD F-350. ATTORNEY REPRESENTING CONSUMER WRITES IN REGARDS TO VEHICLE ENGINE FIRE. *SMD ATTORNEY SENT ADDITIONAL CORRESPONDENCE. *LD UPDATED 07/18/2017 *JS
2016-02-08
STEERING,SUSPENSION,UNKNOWN OR OTHER PROBLEM
- Date Of Incident: 2015-11-25
- VIN: 1FTWW31P85E
- Components: STEERING,SUSPENSION,UNKNOWN OR OTHER
- Summary: I WAS DRIVING ON A TWO LANE BACK ROAD AROUND 45 TO 50 MPH, AND MY TRUCK STARTED VIOLENTLY SHAKING AND I LOST ALL CONTROL OF STEERING. I WENT INTO THE ONCOMING LANE, LUCKILY NO ONE WAS COMING, AND HAD TO HIT MY BRAKES HARD TO GET THE SHAKING TO STOP. IT HAS ALSO HAPPENED WHILE DRIVING AT SPEEDS OF 35-40 ON A CITY STREET AND 60 MPH ON A HIGHWAY. THIS IS KNOWN AS DEATH WOBBLE. THE WOBBLE WAS SO BAD THAT IT LOOSENED THE TRACK BAR AND THE BOLT HOLDING THE POWER STEERING HARD LINE. I LOST ALL POWER STEERING FLUID WITHIN SECONDS. I HAVE RESEARCHED IT, TRIED REPLACING SEVERAL PARTS, LIKE TIE-RODS, AND IT HAS LESSENED A LITTLE BIT, BUT IF I HIT A BUMPY ROAD OR EVEN JUST A PATCH OF NEW PAVEMENT, IT STARTS SHAKING. I HAVE READ A LOT OF OTHER FORD OWNERS ARE EXPERIENCING THIS SAME ISSUE WITH THEIR TRUCKS.
2015-10-27
ENGINE PROBLEM
- Date Of Incident: 2014-03-11
- VIN: 1FTWW33P35E
- Components: ENGINE
- Summary: THE HEAD BOLTS HAVE A KNOWN DEFECT, WHICH FORD FILED A CLASS ACTION SUIT AGAINST THE ENGINE MANUFACTURE NOVASTAR FOR AND WON. THIS DEFECT/WEAKNESS CAN CAUSE THE BOLTS TO FAIL/BREAK CAUSING MANY COMPONENTS TO BECOME DAMAGED. THIS CAN POTENTIALLY CAUSE AN ACCIDENT AND/OR INJURY TO THE VEHICLES OCCUPANTS. I BELIEVE THIS ISSUE NEEDS TO BE ADDRESSED AS A RECALL BECAUSE ACCORDING TO MY RESEARCH ALL OF THE 6.0 DIESEL ENGINES IN THIS YEAR/MODEL ARE AFFECTED.
2015-10-27
ELECTRICAL SYSTEM PROBLEM
- Date Of Incident: 2015-09-04
- VIN: 1FTWW31P45E
- Components: ELECTRICAL SYSTEM
- Summary: VEHICLE STALL/DIE WHILE DRIVING WITHOUT ANY WARNING. WHEN THE VEHICLE DIES, UNABLE TO TURN THE STEERING WHEEL AND NO POWER AT ALL. HAVE A RECALL NUMBER 05S34, BUT FORD DEALERSHIP WON'T REPAIR IT BECAUSE MY VIN ISN'T ON RECALL. WHAT SHOULD I DO NEXT?
2015-09-17
TIRES PROBLEM
- Date Of Incident: 2015-09-13
- Number Of Injuries: 1
- Crash: 1
- VIN: 1FTWF31P95E
- Components: TIRES
- Summary: TIRE FAILURE CAUSING ACCIDENT WITH PROPERTY DAMAGE AND MINOR INJURIES. TIRE WAS THE FRONT LEFT TIRE ON A 2005 FORD F350 4X4 SRW. TIRE HAD APPROXIMATELY 25,000 MILES. ACCIDENT OCCURRED WHILE TOWING A FIFTH WHEEL TOY HAULER TRAILER. TRAILER IS 25' LONG WITH AN APPROXIMATE EMPTY WEIGHT OF 5500 LBS. ALSO IN THE TRAILER WERE PERSONAL EFFECTS INCLUDING ONE MOTORCYCLE WITH AN APPROXIMATE WEIGHT OF 550 LBS. TIRE PRESSURE WAS CHECKED AT 76 PSI COLD 3 DAYS PRIOR TO INCIDENT. ACCIDENT OCCURRED WHILE ON AN INTERSTATE HIGHWAY. THE WEATHER WAS SUNNY WITH TEMPERATURES IN THE 70S TO LOW 80S. SPEED OF VEHICLE AT TIME OF INCIDENT WAS 60-65 MPH. APPROXIMATELY 30 MILES PRIOR TO INCIDENT, A STOP WAS MADE FOR FUEL WITH DRIVER DOING A WALK AROUND VISUAL INSPECTION WITH NO DEFECTS NOTED. LEFT FRONT TIRE BLEW WITH NO ADVANCED WARNING. THIS CAUSED THE VEHICLE TO PULL HARD TO THE LEFT. VEHICLE LEFT THE ROADWAY INTO THE MEDIAN. VEHICLE JACK-KNIFED AND OVERTURNED TO ITS RIGHT SIDE. GUARD RAIL STOPPED VEHICLE FROM ENTERING ONCOMING TRAFFIC. FIFTH WHEEL TRAILER OVERTURNED ONTO ITS RIGHT SIDE. OCCUPANTS OF VEHICLE, ONE ADULT MALE DRIVER AND ONE ADULT FEMALE PASSENGER SELF EXTRICATED VIA THE BACK WINDOW. DRIVER UNINJURED. PASSENGER NOTED MINOR CUTS, 'ROAD RASH', BRUISES AND PAIN TO LEFT WRIST. BOTH OCCUPANTS REFUSED TREATMENT AND TRANSPORT BY EMERGENCY RESPONDING UNITS. UPON INSPECTION, IT APPEARS, TO THE OPINION OF THE DRIVER, THAT THE TIRE FAILED AT THE SIDEWALL NEAR THE BEAD CAUSING A RAPID LOSS OF AIR AND SUBSEQUENT DELAMINATION OF TIRE STRUCTURE. THE TRUCK AND FIFTH WHEEL WAS TOTALLY DAMAGED BEYOND REPAIR. THE FEMALE PASSENGER CONTINUES TO MONITOR INJURIES WITH NO MEDICAL ATTENTION SOUGHT AT THIS TIME. TRUCK AND TRAILER WAS TOWED BY A LOCAL SALVAGE AND RECOVERY COMPANY TO THEIR YARD. TRUCK AND TRAILER WERE RELEASED BY THE DRIVER/OWNER TO THE INSURANCE COMPANY FOR INSPECTION, ALTHOUGH HE MAINTAINS OWNERSHIP OF VEHICLES.
2015-08-20
WHEELS PROBLEM
- Date Of Incident: 2015-08-01
- Components: WHEELS
- Summary: THIS HAS TO DO WITH 19.5" WHEELS MANUFACTURED BY VISION WHEEL,SPECIFICALLY WHEEL # 81A-9770MBO. ON THE BACK OF THE WHEEL THERE IS A RELIEF MACHINED AROUND EACH LUG HOLE THAT IS ABOUT 1/8"DEEP X 3/4" IN DIA. WHETHER THIS IS A MANUFACTURING DESIGN OR A FLAW I AM NOT SURE,BUT PREVIOUS WHEELS OF THE SAME MODEL NO. DO NOT HAVE THIS AND ARE FLAT ON THE BACK. SHOULD THE LUGS NUTS BE OVER TIGHTENED IT CRACKS THE RIM AROUND THE LUG HOLE AND STARTS TO PULL THROUGH. I FOUND THIS SHORTLY AFTER I GOT MY TRUCK BACK FROM THE TIRE SHOP AND WAS LOOKING AT THE NEW WHEELS.IT IS NOT READILY NOTICEABLE AND WAS JUST LUCK THAT I SAW IT. MY CONCERN IS THAT THIS COULD HAPPEN ANY TIME A WHEEL IS TAKEN OFF FOR SOME SERVICE OR ANOTHER. IF THE WHEEL LUG NUTS GET OVER TORQUED THIS OCCURS. THESE WHEELS ARE USED PRIMARILY BY PEOPLE THAT CARRY HEAVY LOADS AS THE 19.5 TIRES AFFORD BETTER STABILITY. SHOULD SOMEONE NOT BE AWARE OF THIS ISSUE THERE IS THE POSSIBILITY OF LOOSING A TIRE. THIS COULD BE RESOLVED SIMPLY BY NOT MACHINING THE BACK OF THE WHEEL AS WAS NOTED ABOVE. I BELIEVE THIS COULD BE A HAZARD. CONTACT INFO CAN BE OBTAINED HERE: HTTP://WWW.VISIONWHEEL.COM/CONTACT.CFM
2015-03-01
ENGINE,FUEL/PROPULSION SYSTEM PROBLEM
- Date Of Incident: 2015-03-01
- VIN: 1FTWX31P35E
- Components: ENGINE,FUEL/PROPULSION SYSTEM
- Summary: FOR THE PAST WEEK MY TRUCK HAS BEEN TAKING LONGER TO START THEN NORMAL TODAY IT STARTED TO STALL ON MY I WAS ABLE TO GET IT HOME WHILE IT STALLED 4 MORE TIMES ON THE WAY. SHOPPED AT A FRIENDS SHOP ON THE WAY HOME AND HAD THEM SCAN THE COMPUTER FOUND OUT MY FICM IS NO GO MY IPR IS BAD AND MY STC FITTING IS BAD THEY FOUND THE STC WHEN THEY PULLED THE TURBO ASWELL AS MY DUMMY PLUGS. *TR
2015-02-03
ENGINE PROBLEM
- Date Of Incident: 2015-02-03
- VIN: 1FDWF37P65E
- Components: ENGINE
- Summary: TL*THE CONTACT OWNS A 2005 FORD F-350 SD. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 60 MPH, THE VEHICLE STALLED AS THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 124,723.
2014-07-08
SERVICE BRAKES PROBLEM
- Date Of Incident: 2011-06-16
- VIN: 1FTWW33P35E
- Components: SERVICE BRAKES
- Summary: TL* THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT STATED WHILE DRIVING AT 15 MPH, THE BRAKE LIGHT FAILED TO ILLUMINATE WHENEVER THE BRAKES WERE ENGAGED. ALSO, THE TBC WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE CONNECTOR TO THE BREAK LIGHT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNAVAILABLE AND THE CURRENT MILEAGE WAS 140,000.
2014-06-17
ENGINE PROBLEM
- Date Of Incident: 2014-05-13
- VIN: 1FTWW33P25E
- Components: ENGINE
- Summary: APPROXIMATELY 16,000 MILES PRIOR TO THIS INCIDENT (96,450) THE VEHICLE HAD A LACK OF TOWING POWER. I TOOK IT TO FORD, AND THEY TOLD ME THAT IT WAS THE EGR COOLER AND OIL COOLER. THE SERVICE MANAGER ADVISED ME THAT THIS HAPPENS TO EVERY 6.0 LITER DIESEL. HE STATED THEY UPDATED THE COOLERS TO FIX THE PROBLEM (PRETTY MUCH ADMITTING THAT THEY DID NOT BUILD IT RIGHT). I SEARCHED ONLINE AND FOUND THIS TO BE TRUE, BUT FOR SOME REASON THERE IS NO RECALL. $4,730.78 LATER, MY VEHICLE WAS FIXED. ALTHOUGH I DO TOW WITH THE VEHICLE (THAT'S WHAT ITS MADE FOR), I BABY THE VEHICLE. I DO OIL CHANGES EVERY 3000 (RECOMMENDED AT 5000) AND CHANGE THE FUEL FILTER 2 TIMES A YEAR (RECOMMENDED EVERY 12,000). THREE YEARS LATER AND ONLY 16,000 MILES LATER (113,239) THE VEHICLE AGAIN HAD A LACK OF POWER. I TOOK IT TO FORD AGAIN, AND THEY TOLD ME IT WAS THE EGR COOLER, OIL COOLER, AND HEAD GASKETS. I TOLD THE SERVICE MANAGER THAT I JUST HAD THE EGR COOLER AND OIL COOLER REPLACED, BUT IT WAS OUT OF THE REPAIR WARRANTY. HE SAID ALL OF THESE TRUCKS HAVE THESE PROBLEMS. $7,937 (DISCOUNTED) AND TWO WEEKS LATER I RECEIVED MY VEHICLE BACK. MY FAMILY HAS USED FORD DIESEL TRUCKS FOR YEARS AND NORMALLY GET 250,000 OUT OF THEM BEFORE ANY MAJOR REPAIRS. FORD DOES NOT STAND BEHIND THEIR PRODUCT LIKE THEY USED TO. I WILL NEVER BUY ANOTHER FORD. *TR
2014-02-05
ELECTRICAL SYSTEM PROBLEM
- Date Of Incident: 2014-02-02
- Components: ELECTRICAL SYSTEM
- Summary: TL* THE CONTACT OWNS A 2005 FORD F-350SD. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS RESTARTED AND RESUMED NORMALLY. THE FAILURE RECURRED AND THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 05V27000 (ELECTRICAL SYSTEM) HOWEVER, THE VIN WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 137,000. THE VIN WAS UNAVAILABLE.
2014-01-25
STEERING,SUSPENSION PROBLEM
- Date Of Incident: 2013-09-25
- Components: STEERING,SUSPENSION
- Summary: I HAVE A 2005, CREW CAB, SHORT BED, 6.0 DIESEL F-350. WHEN DRIVING AT 55-75MPH ON THE HIGHWAY, I PASSED A SMALL BUMP TRIGGERING A RIGOROUS SHAKING OF THE FRONT END. I COULD NOT APPLY BRAKES RAPIDLY, AND THE STEERING WHEEL BEGAN TO SHAKE. I BARELY HAD CONTROL OF THE VEHICLE, BUT AFTER FINALLY SLOWING DOWN TO A STOP THE SHAKING STOPPED. IT WAS VERY DANGEROUS, AND HAS HAPPENED 6 TIMES SINCE AT 55-75MPH. *TR
2014-01-03
AIR BAGS PROBLEM
- Date Of Incident: 2013-11-23
- Number Of Injuries: 1
- Number Of Deaths: 1
- Crash: 1
- VIN: 1FTWW32P95E
- Components: AIR BAGS
- Summary: FORD F350 PULLING A 31' TRAILER CRASHED INTO REAR OF A COMMERCIAL TRUCK/TRAILER DUE TO ICY ROAD CONDITIONS. AIR BAGS DID NOT ACTIVATE ON IMPACT. PASSENGER IN RIGHT/FRONT SEAT WAS CRUSHED DUE TO IMPACT. *TR
2013-10-15
ELECTRICAL SYSTEM PROBLEM
- Date Of Incident: 2013-09-24
- VIN: 1FTWW33P15E
- Components: ELECTRICAL SYSTEM
- Summary: TL* THE CONTACT OWNS A 2005 FORD F-350 SD. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START. AFTER SEVERAL ATTEMPTS THE CONTACT WAS ABLE TO START THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE TECHNICIAN STATED THE FUEL INJECTION CONTROL MODULE WOULD HAVE TO BE REPLACED. THERE WAS A RECALL UNDER NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM) HOWEVER, THE MANUFACTURER STATED THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 97,300.
2013-07-15
FUEL SYSTEM, DIESEL,ENGINE PROBLEM
- Date Of Incident: 2013-06-15
- VIN: 1FTWW31P85E
- Components: FUEL SYSTEM, DIESEL,ENGINE
- Summary: COMING HOME FROM A CAMPING TRIP WITH A 5TH WHEEL CAMPER & TRUCK JUST STOPPED WORKING. COME TO FIND OUT THE STC FITTING ON HIGH PRESSURE OIL PUMP SHOT APART & CRACKED REAR TIMING COVER. AFTER BEING STUCK ON THE HIGHWAY FOR OVER 8 HOURS, STRANDED AT THE CAMPGROUND FOR 4 MORE DAYS & $3000 TO GET IT FIXED, WE THEN FINDING OUT THAT THIS IS A COMMON PROBLEM WITH THIS ENGINE. THIS STC FITTING HAS SINCE BEEN CHANGED BY THE MANUFACTURER SO THAT IT IS ONE PIECE NOW, HOWEVER THERE HAS NOT BEEN A RECALL ON IT. WE HAVE SEVERAL FORD VEHICLES AND IT IS VERY UPSETTING TO GO THROUGH ALL OF THIS WHEN A SIMPLE RECALL COULD HAVE AVOIDED IT. THANK YOU FOR YOUR ATTENTION TO RESOLVING THIS MATTER & HELPING US GET A REFUND FOR THE $3000. *TR
2013-05-23
ELECTRICAL SYSTEM PROBLEM
- Date Of Incident: 2012-12-23
- VIN: 1FTWW33P65E
- Components: ELECTRICAL SYSTEM
- Summary: TL* THE CONTACT OWNS A 2005 FORD F-350 SD. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT OFFER ANY ASSISTANCE, STATING THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 170,000 AND THE CURRENT MILEAGE WAS 180,000. *TR
2013-05-07
TIRES PROBLEM
- Date Of Incident: 2012-08-28
- VIN: 1FTWW32P75E
- Components: TIRES
- Summary: TL* THE CONTACT OWNS A 2005 FORD F-350 SD EQUIPPED WITH MICHELIN TIRES, SIZE: LT245/75/R17 TIRES(N/A). THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THE HOOD ON THE TRUCK, BEGAN TO VIBRATE IN A VIOLENT MANNER. WITHIN 2-3 SECONDS, THE FRONT PASSENGER'S SIDE TIRE EXPLODED WHICH CAUSED THE VEHICLE TO PULL TOWARD THE RIGHT AND SWAY UNCONTROLLABLY OFF ROAD, THROUGH SAND, BRUSH ROCKS, ACROSS A CULVERT, WHICH CAUSED THE FRONT END OF THE VEHICLE, TO BECOME BURIED DEEP IN THE SAND. THERE WAS DAMAGE TO THE VEHICLE. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE WHERE THE DEFECTIVE TIRE WAS REPLACED WITH A SPARE. THE VEHICLE WAS THEN TAKEN TO A TIRE CENTER WHERE THE FRONT PASSENGER AND DRIVER'S SIDE TIRES WERE REPLACED. THE TIRE CENTER REPLACED THE DEFECTIVE TIRE FREE OF CHARGE. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 82,462. UPDATED 6/17/13 *CN THE CONSUMER STATED THE RETAIL ESTABLISHMENT REFUNDED THE COST OF THE BLOWN TIRE, STATING IT WAS DEFECTIVE. MICHELIN DISAGREED WITH THE RETAIL ESTABLISHMENTS FINDINGS AND STATED THE TIRE WAS NOT DEFECTIVE. MICHELIN STATED THEIR INSPECTION REVEALED A RADIAL BREAK THROUGH THE CASING IN THE CROWN AREA FROM BEAD TO BEAD. A PORTION OF THE TREAD AND BOTH STEEL BELTS WERE DETACHED AND MISSING IN THAT AREA EXPOSING THE RADIAL CASING PILED. MICHELIN, WENT ON TO STATED, THAT INDICATED THE INNER LINER ALLOWING AIR TO INFILTRATE INTO THE CASING. AS THE TIRE REMAINED IN SERVICE, THE AIR INFILTRATION PROGRESSED, ULTIMATELY CAUSING THE TREAD TO DETACH. UPDATED 06/25/13
2013-04-29
STEERING PROBLEM
- Date Of Incident: 2013-04-17
- VIN: 1FTWW33P85E
- Components: STEERING
- Summary: DRIVING ST HIGHWAY SPEED (50-55MPH) I RAN OVER THREE SMALL BUMPS IN SUCCESSION, THE STEERING WHEEL WENT INTO A VIOLENT SIDE TO SIDE SHAKING AND I EXPERIENCED A SEVERE AND VIOLENT SHAKING OF THE ENTIRE FRONT END OF THE TRUCK. I MANAGED TO SLOW THE TRUCK AND PULL TO THE SHOULDER OF THE DIVIDED HIGHWAY. I GOT OUT AND INSPECTED THE TRUCK TO SEE IF THERE WAS ANY DAMAGE. I COULD SEE NONE SO I DROVE CAREFULLY BACK ON TO THE HIGHWAY AND THE TRUCK SEEMED TO DRIVE OK FROM THAT POINT ON. I TOOK THE TRUCK TO A FRONT END ALIGNMENT SHOP AND HAD THE FRONT END AND SUSPENSION CHECKED. THEY SAID IT ALL LOOKED GOOD, BUT AFTER THAT ABOUT A MONTH LATER I HAD THE SAME THING HAPPEN AGAIN ON AN INTERSTATE HIGHWAY. SAME DEAL, I HIT A SUCCESSION OF SMALL BUMPS , THEN ALL HELL BROKE LOOSE, VIOLENT SHAKING AND OSCILLATION OF THE STEERING WHEEL. I WAS FORCED TO PULL OVER TO THE BERM IN HEAVY TRAFFIC AND HAD TO PULL BACK OUT INTO FAST MOVING TRAFFIC. THESE F-350'S ARE A DEATH TRAP ! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
2013-04-25
ELECTRICAL SYSTEM PROBLEM
- Date Of Incident: 2013-04-22
- VIN: 1FTWX31P65E
- Components: ELECTRICAL SYSTEM
- Summary: TL* THE CONTACT OWNS A 2005 FORD F-350 SD. THE CONTACT STATED THAT THE VEHICLE LUNGED FORWARD AND STALLED. THIS FAILURE OCCURRED ON MORE THAN ONE OCCASION. THE CONTACT STATED THAT THE VEHICLE WOULD NOT ALWAYS RESTART. THE CONTACT FOUND NHTSA RECALL CAMPAIGN ID NUMBER: 05V270000 (ELECTRICAL SYSTEM) BUT THE MANUFACTURER STATED THE VEHICLE WAS NOT INCLUDED. THE DEALER TOLD THE CONTACT THEY WERE NOT SURE OF WHAT CAUSED THE FAILURE. THE FAILURE MILEAGE AND CURRENT MILEAGES WAS 70,000. *TR
2013-03-29
ENGINE AND ENGINE COOLING PROBLEM
- Date Of Incident: 2010-08-31
- VIN: 1FTWW31P65E
- Components: ENGINE AND ENGINE COOLING
- Summary: TL* THE CONTACT OWNS A 2005 FORD F350 SD. THE CONTACT STATED THAT WHILE DRIVING UPHILL, THE VEHICLE OVERHEATED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT THE TURBO NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THE VEHICLE WAS NOT DRIVEN ENOUGH, WHICH WAS THE CAUSE OF THE FAILURE. THE FAILURE MILEAGE WAS 21,768. UPDATED 5/9/13 *CN
2013-02-27
ENGINE PROBLEM
- Date Of Incident: 2013-02-17
- VIN: 1FTWW33P65E
- Components: ENGINE
- Summary: TL* THE CONTACT OWNS A 2005 FORD F-350 SD. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, HE NOTICED A LOT OF STEAM COMING FROM HIS TAIL PIPE. THE VEHICLE WAS TAKEN TO THE DEALER. AFTER DIAGNOSIS, THEY ADVISED HIM THAT EGR COOLER AND HEAD GASKETS FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED FOR THE EGR COOLER AND HEAD GASKETS. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 40,925.
2013-01-16
STEERING PROBLEM
- Date Of Incident: 2007-01-01
- Components: STEERING
- Summary: TL* THE CONTACT OWNS A 2005 FORD F-350 SD. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE STEERING WHEEL AND FRONT END OF THE VEHICLE STARTED TO SHAKE. THE CONTACT RELEASED THE ACCELERATOR PEDAL AND THE SHAKING BECAME MORE EXTREME. AFTER DEPRESSING THE BRAKES, THE VEHICLE WAS MOVED OFF THE ROADWAY AND THE CONTACT INSPECTED THE VEHICLE. THE CONTACT FOUND NOTHING LOOSE OR HANGING. THE VEHICLE WAS THEN TAKEN TO A DEALER WHERE THE CONTACT WAS INFORMED THAT THE VEHICLE WAS PERFORMING NORMALLY WHEN DRIVING AT HIGHWAY SPEEDS. THE MANUFACTURER WAS CONTACTED BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 20,000. THE CURRENT MILEAGE WAS APPROXIMATELY 62,000. THE VIN WAS UNAVAILABLE.
2013-01-03
FUEL/PROPULSION SYSTEM PROBLEM
- Date Of Incident: 2012-08-10
- VIN: 1FTWW32P45E
- Components: FUEL/PROPULSION SYSTEM
- Summary: TL* THE CONTACT OWNS A 2005 FORD F-350 SD. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE VEHICLE STALLED WITH THE ILLUMINATION OF THE ABS, WRENCH AND BATTERY WARNING LAMPS. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE FUEL INJECTOR MODULE NEEDED TO BE REPLACED. THE FAILURE RECURRED AND THE VEHICLE WAS TAKEN BACK TO THE DEALER. THE REPRESENTATIVE NOTIFIED HER THAT THEY COULD NOT PROVIDE ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 05V270000 (ELECTRICAL SYSTEM:WIRING). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 151,016 AND THE CURRENT MILEAGE WAS 158,546.
2005 Ford F-350 sd recalls
The National Highway Traffic Safety Administration (NHTSA) has issued 4 recalls for different components of the 2005 Ford F-350 sd.
2020-12-09
- Manufacturer: Icon Vehicle Dynamics, LLC
- Components: STEERING
- Summary: Icon Vehicle Dynamics, LLC (Icon) is recalling all 05-UP FSD 2.5 Centerline Stabilizer Kits with part number 65050. The kits were sold as an accessory for certain 2005-2021 Ford F-250 4X4 and F-350 4X4 pickup trucks. The foam ring inside the stabilizer "through shaft" may block the piston ports, possibly causing the steering to lock up.
- Consequence: If the steering locks, it can increase the risk of a crash.
- Remedy: Icon will notify owners, and dealers will install a new shock assembly with a revised foam ring and steel support disc, free of charge. The recall began December 21, 2020. Owners may contact Icon customer service at 1-951-689-4266.
2011-07-13
- Manufacturer: FORD MOTOR COMPANY
- Components: EXTERIOR LIGHTING:TAIL LIGHTS
- Summary: FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
- Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
- Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
2005-06-10
- Manufacturer: FORD MOTOR COMPANY
- Components: ELECTRICAL SYSTEM:WIRING
- Summary: CERTAIN PICKUP TRUCKS, SPORT UTILITY VEHICLES AND VANS EQUIPPED WITH 6.0L DIESEL ENGINES MAY EXPERIENCE STALLING WITHOUT WARNING WHILE DRIVING AND MAY OR MAY NOT RESTART.
- Consequence: SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR.
- Remedy: DEALERS WILL UPGRADE THE FUEL INJECTION CONTROL MODULE (FICM) WIRE HARNESS OR REPLACED, AND/OR HAVE A NEW INJECTION CONTROL PRESSURE (ICP)) SENSOR CONNECTOR INSTALLED FREE OF CHARGE. THE RECALL BEGAN ON JULY 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
2005-06-09
- Manufacturer: FORD MOTOR COMPANY
- Components: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
- Summary: ON CERTAIN PICKUP TRUCKS AND CHASSIS CAB VEHICLES EQUIPPED WITH 5.4L OR 6.8L GASOLINE ENGINES, THE FUEL JUMPER LINE MAY HAVE AN INCORRECT END FORM.
- Consequence: THE FUEL LINE MAY SEPARATE AT THE CONNECTION TO THE MAIN FUEL BUNDLE. IF THE FUEL LINE SEPARATES, AN OPERATOR MAY NOTICE A GASOLINE ODOR AND/OR FUEL ON THE GROUND, LOSS OF POWER, AND THE ENGINE WILL EVENTUALLY STALL. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
- Remedy: DEALERS WILL INSTALL AN EXTERNAL RETENTION CLIP AT THE FUEL JUMPER LINE TO THE MAIN FUEL BUNDLE CONNECTION. THE RECALL BEGAN ON JUNE 20, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Additional sources
More sources of information about 2005 Ford F-350 sd problems:
Newby - 2005 F-350 Problems, repair or cut losses - Ford Truck ...
https://www.ford-trucks.com/forums/1028714-newby-2005-f-350-problems-repair-or-cut-losses.html
Jan 12, 2011 ... I don't know if this is a vocal minority or if there are serious issues. What are the expectations for this being a long term fix and not other ...
Q&A: 2005 Ford F350 Super Duty Diesel Electrical Problems
https://www.justanswer.com/ford/d2iic-electrical-problems-2005-ford-f350-super-duty-diesel.html
Oct 25, 2019 ... I apologize, I stink at showing sympathy through a keyboard but I do care about you, your vehicle's issues, & the funds you're spending.
2005 Ford F-350 Super Duty Problems and Complaints - 12 Issues
https://repairpal.com/2005-ford-f-350-super-duty/problems
Problem with your 2005 Ford F-350 Super Duty? Our list of 12 known complaints reported by owners can help you fix your 2005 Ford F-350 Super Duty.
Q&A: 2005 Ford F-350 Super Duty Lariat - Common Issues & Solutions
https://www.justanswer.com/ford/5l181-ford-f-350-super-duty-lariat-2005-ford-f-350-6-0.html
Sep 21, 2011 ... Normally if you raise the rpm to about 3000 and it fluctuates it is caused by a low oil level or a bad IPR (Injector Pressure Regulator) which ...
2005 Ford F-350 6.0 diesel. Keep it or dump it? - Montana Owners ...
https://www.montanaowners.com/forums/showthread.php?t=40324
I own a 2005 Ford F-350 DRW Lariat that is is showroom condition on the outside. The problem is the damn 6.0 diesel engine. The truck has 47,000 ...
Other years of Ford F-350 sd
Are you having problems with your 2005 Ford F-350 sd?
Leave your review of 2005 Ford F-350 sd