1997 Volvo 964 problems
The Volvo 900 Series is a range of executive cars produced by the Swedish manufacturer Volvo Cars from 1990 to 1998. The 900 Series was introduced in 1990 to replace the 700 Series from which it derived. Prior to the end of its production, the 960 was renamed as the Volvo S90 (saloon) and Volvo V90 (estate), and the 940 was renamed 940 Classic, becoming the last rear-wheel-drive cars from Volvo, until the 2023 Volvo XC40.
Visible differences between the 700 and the 900 Series included redesigned rear styling of the saloon models (late 700 estates and early 900 estates are visually identical). The 960 was introduced in 1991 along with a new family of modular engines, and then was substantially revised for the 1995 model year, improving the handling. The range was augmented by the new Volvo 850 in 1991. The last of the 900s was sold in 1998. Some 900 Series were built as chassis for ambulances and hearses after the main production run had been completed.
Volvo 940
Introduced in September 1990, the 940 was essentially a cosmetic reskin of the 740 aside from the completely redesigned rear from the C pillar back on the sedan. The new, taller trunk did diminish rearward vision but provided a larger opening to a larger boot than on the 700-series. The dashboard and seats were all new, offering a bit more headroom and the option of an integrated child booster seat in the rear. All drivetrains, and most options available in the 940 had been available in the 740, with the exception of the 780 Coupé. The 940 was more closely related to the 740 than the 760, sharing similar drivetrain choices and sheet metal from the A-pillar forward. In contrast, the 960 was an evolution of the 760. The 760 / 960 front sheet metal, independent rear suspension, dashboard, and other interior features were all exclusive to the two upscale models. The 940 estate, introduced in May 1991, was almost identical to its 740 estate predecessor.
The engines options were carried over from the 740, with 8-valve 2-litre (B200) and 2.3-litre (B230) four cylinder gasoline engines, either naturally aspirated or turbocharged, as well as the familiar 2.4-litre Volkswagen six-cylinder diesel and turbodiesels being fitted. There were also 16-valve versions of the gasoline engines fitted on some 1991 and 1992 models (B204, B234, naturally aspirated). The 2-litre 16-valve engine was fitted to the 940 base model in Italy at the time of introduction, to mark it being a step up from the 740. After the 740 was discontinued, the eight-valve engine found its way into the 940 as well. The 2.3-litre turbocharged version produces 165 PS (121 kW); Volvo sold a chip tuning kit called Turbo+ which boosted the power to 190 PS (140 kW).
In 1994, gasoline engine range was limited to 2.3 engines in Britain, but the 2.0-litre engines remained available in markets with tight tax limits, such as Italy, Belgium, and Portugal. A low-pressure turbocharged version of the B230, the B230FK, debuted in 1994 – maximum power was only up slightly over the B230FB, from 131 to 135 PS (96 to 99 kW), but torque increased throughout the range and there was virtually no turbo lag due to the small size of the charger. The 155 PS (114 kW) turbocharged 2.0 was first presented in February 1991. Originally intended for Italy and other markets with significant taxation thresholds at two litres, it was later also installed in the British-market 940 SE. The most commonly found engines on 940s were the naturally aspirated B230FB with 131 PS (96 kW) (all markets but US), B230FD with 115 PS (85 kW) (mainly for the US market), the turbocharged B230FK and FT, and the D24TIC diesel engine with 116 PS (85 kW). The share of sales for the turbodiesel were much lower for the 900-series than in earlier years.
Engines were fitted with either a 5-speed (M47) or 4-speed+overdrive (M46) manual gearbox or an automatic transmission, either Aisin-Warner AW70/71/72 (3-speed+overdrive) or ZF 4HP22 (4-speed) for some B230FB (or E) and diesel engines. In 1995, the manual gearbox was replaced with a full 5-speed (M90), and the ZF was abandoned for gasoline engines and fitted only on diesels.
The SE emblem denoted very different trim and engine levels in different countries. In Sweden, the 940 SE was an ordinary non-turbo 940 with some optional extras as standard, most notably painted mirrors and bumpers. In the UK it was a high trim level available with all engines (from 2.0 to 2.3 turbo). In Australia, the 940 SE was a high trim level with only the 2.3 Turbo B230FT with some extras as standard and featured, rather unusually, full painted bumpers. In Thailand the 940 SE was a Turbo (LPT) model with leather seats, ABS brakes and SRS Airbag. In the US, the 940 SE utilised the body from the 960 (different dashboard, firewall, hood, recessed windscreen wipers etc) with the four-cylinder B230FT engine, the 940 SE badge presumably chosen by Volvo in order to maintain the link between name and number of cylinders.
From MY 1993 on, in Italy all 940 estates were badged "Polar" (engine B200F) or "Super Polar" (engine B200FT). Towards the end of the model cycle, certain countries (as Sweden, Germany and Switzerland) received a well equipped, limited series badged "Classic". Production of the 940 series extended from 1990 to 1998 with a total of 246,704 units of sedan and 231,677 units of estate. The Volvo 940 is among the last in the long-running line of rear-wheel drive cars from Volvo.
Social links
Common 1997 Volvo 964 problems
The Volvo 960, produced from 1990 to 1998, is known for its smooth ride, quiet operation, and solid feel. However, like any vehicle, it has its share of common problems and issues that owners have reported. Here are some of the most frequently mentioned problems with the 1997 Volvo 960, based on owner complaints and reports:
- Fuel Rail Leakage Problems: The fuel rail on the 1997 Volvo 960 is prone to leaking, particularly at the plug on the very end of the fuel rail towards the front of the car.
- Intake Manifold Gasket Leaks: The intake manifold gasket on the 1997 Volvo 960 can leak, causing coolant to mix with fuel and air. This issue can result in a rough idle, poor performance, and reduced fuel efficiency. The intake manifold gasket can be replaced to fix this problem.
- Head Gasket Leaks: The head gasket on the 1997 Volvo 960 can also leak, causing coolant to mix with oil and engine gases. This issue can result in overheating, poor performance, and reduced fuel efficiency. The head gasket can be replaced to fix this problem.
- Charcoal Vapor Canister Replacement: The charcoal vapor canister on the 1997 Volvo 960 can fail, causing a strong gas smell inside the car. This issue can be caused by a crack in the canister or a loose connection. The charcoal vapor canister can be replaced to fix this problem.
- Stuck Thermostat: The thermostat on the 1997 Volvo 960 can become stuck, causing the engine to run too hot or too cold. This issue can result in poor performance, reduced fuel efficiency, and increased wear and tear on the engine. The thermostat can be replaced to fix this problem.
- Coolant Loss: The 1997 Volvo 960 can lose coolant due to leaks in the coolant reservoir cap or behind the water pump. This issue can result in overheating, poor performance, and reduced fuel efficiency. The coolant system can be inspected and repaired to fix this problem.
- Oil Leaks: The 1997 Volvo 960 can leak oil due to worn or damaged seals, gaskets, or fittings. This issue can result in reduced engine performance, reduced fuel efficiency, and increased wear and tear on the engine. The oil system can be inspected and repaired to fix this problem.
These are some of the most common problems reported by owners of the 1997 Volvo 960. Regular maintenance, such as changing the coolant and oil regularly, can help prevent these issues from occurring or becoming more serious. If you are considering purchasing a 1997 Volvo 960, it is important to thoroughly inspect the car and address any issues before purchasing.
Is the Volvo 850 engine reliable?
According to reports from owners, the 850 can go over 200,000 miles with little to no problems. Some owners have shared that the 850 can go up to 300,000 to 400,000 miles as long as you take care of it by keeping up with its maintenance and service schedule.
What is the life expectancy of a Volvo engine?
It can also vary depending on the make and year of your Volvo. That being said, with the proper care the average lifespan of a Volvo is typically 20 years with over 200,000 miles.
How much horsepower does a 1997 Volvo 850 have?
168 to 240 hp1997 Volvo 850 / Horsepower
How fast is the 1997 Volvo 850? The 1997 850 ranges in power from the Sedan 4D with 168 horsepower to the R Sedan 4D with 240 horsepower.
What is high mileage for Volvo?
Your car must have done over 150,000 miles to qualify.
Is the Volvo 850 engine reliable?
According to reports from owners, the 850 can go over 200,000 miles with little to no problems. Some owners have shared that the 850 can go up to 300,000 to 400,000 miles as long as you take care of it by keeping up with its maintenance and service schedule.
Do Volvo engines last long?
So long as regular maintenance schedules are followed, a Volvo vehicle will on average last for 20 years. can also vary depending on the make and year of your Volvo. That being said, with the proper care the average lifespan of a Volvo is typically 20 years with over 200,000 miles.
What model Volvo was most reliable?
The following Volvo models are often ranked as the most reliable:
- S60.
- V60.
- V70.
- XC40.
- XC60.
- XC90.
Is Volvo reliable like Toyota?
While Volvos aren't as reliable as Japanese makes like Honda and Toyota, they still hold up very well and shouldn't cause you too many issues. Compared to some other luxury brands, Volvo comes out on top in terms of dependability in the long run.
1997 Volvo 964 complaints
The NHTSA has received 0 complaints about various vehicle components related to the 1997 Volvo 964.
You can leave your car complaint via the special form below.
1997 Volvo 964 recalls
The National Highway Traffic Safety Administration (NHTSA) has issued 1 recalls for different components of the 1997 Volvo 964.
- Manufacturer: VOLVO CARS OF NA, INC.
- Components: VEHICLE SPEED CONTROL
- Summary: THE SCREWS WHICH ATTACH THE THROTTLE PLATE TO ITS AXLE (SHAFT) CAN LOOSEN ALLOWING THE THROTTLE PLATE TO COME IN CONTACT WITH THE THROTTLE HOUSING.
- Consequence: THIS CONDITION COULD PREVENT THE THROTTLE FROM RETURNING TO IDLE POSITION INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
- Remedy: DEALERS WILL REPLACE THE THROTTLE HOUSING.
Additional sources
More sources of information about 1997 Volvo 964 problems:
740, 940 common problems
May 14, 2021 ... 1997 - 1998 V90/S90. Search this topic ... 96 964 silver, 145807, diff&trans/engine self-dest, crushed : ... what are common leaks 2001 volvo c70 ...
How reliable are the 960's? | SwedeSpeed - Volvo Performance ...
May 29, 2004 ... ... problems with it, the AC (like all Volvos ... 1997 Volvo 960 $10,295 66,193 Stillman Volvo Sedan Dark Gray 1,360 mi. ... I had a 95 964 3.0 24v and ...
Who likes the 960
Dec 27, 2018 ... Over the 20 years I've been driving Volvo's I've been through 240's, 740's, 780, and a 940. And an XC and an 850. To many ongoing problems with ...
2006 Volvo XC 90 2.5T : What issues arise? | SwedeSpeed - Volvo ...
Nov 27, 2018 ... Past: 89 744 GLE 16V, 90 745 GLE 16V, 95 964, 94 854 T5, 01 S40 1.9T, 99 C70 HPT, 01 S60 T5, 07 VW GTI, 98 V70 GLT, 99 S70AWD, 98 V70XC, 97 854 ...
92-98 6cyl lifter ticking: is it common to specific years?
May 14, 2021 ... Robert told me it was a rare problem but others on here have said its a common issue. ... 96 964 silver, 145807, diff&trans/engine self-dest, ...
Other years of Volvo 964
Are you having problems with your 1997 Volvo 964?
Leave your review of 1997 Volvo 964