Gmc Savana problems
The Chevrolet Express (also known as the GMC Savana) is a series of full-size vans produced by General Motors since 1996. The successor to the Chevrolet G-series van, the Express is produced in passenger and cargo variants. Alongside the standard van body, the line is offered as a cutaway van chassis; the latter vehicle is a chassis cab variant developed for commercial-grade applications, including ambulances, buses, motorhomes, and small trucks.
In production for a single generation since 1995, over 2.5 million examples of the Express and the Savana have been produced. One of the longest-produced designs in American automotive history, the Express/Savana are rivaled only by the Jeep Wagoneer and Dodge Ram Van for longevity.
Since 1995, General Motors has assembled the Express and Savana at its Wentzville Assembly facility (Wentzville, Missouri). Also, since 2017, GM has sourced commercial cutaway-chassis production from Navistar through its Springfield Assembly Plant (Springfield, Ohio).
Social links
Gmc Savana model years
Common Gmc Savana problems
The GMC Savana 2500, a hard-working van that has been giving its competitors a run for their money, has been subject to a few engine problems. One common issue is the transmission getting stuck in the third gear, which is a problem with the 4L60E and 4L65E types of transmission. This issue may be caused by a malfunction with the instrument cluster, with DTC set at P0753, P0740, P1860, and P0785. The most likely culprit is an open circuit between the transmission and fuse panel or a blown fuse. If the fuse has no battery voltage, the ignition switch may need to be replaced.
Another common problem with the 4L60E Transmission RPO M30 is an abnormally harsh 1-2 shift, which may indicate excessive bore wear that holds the regulator valves and TCC isolator. This results in extreme line pressure, and the only solution is the replacement of the 4L60E valve body with isolator valves and a revised TCC regulator.
When there is no movement when shifting to the third gear or Drive position, it indicates that the GMC Savana 2500 has problems. This issue can be resolved by replacing the forward sprag assembly. Additionally, there is a common problem with the 4L60E Transmission and 4L65E Transmission, where the first and third gears seem to function correctly, but there are problems with the 2nd, 3rd, and reverse gears. The solution is to replace the heat-treated 4L60E/4L65 sun gear, which is a failure of the reaction sun gear.
The most common problem reported by GMC Savana owners is a delayed starting problem, which is a problem with the 2000 GMC Savana. The average cost to fix this problem is $3,500, and it occurs at an average mileage of 44,000 mi.
The National Highway Traffic Safety Administration’s (NHTSA) Office of Defects Investigation is looking into a complaint that alleges an issue with the 6L90 transmission used by 2016-2018 and 2021-2022 Chevrolet Express and GMC Savana cutaway models in the U.S. A complaint filed with the NHTSA claims that impacted vehicles could experience a loss of power when shifting into drive or reverse. The complaint notes that many of the Chevrolet Express and GMC Savana models impacted are used as school buses and ambulances and says that a loss of motive power could prevent ambulances from transporting patients and could force students to leave a school bus mid-route.
In conclusion, the GMC Savana 2500 has been subject to a few engine problems, including transmission issues, delayed starting problems, and leaking coolant from a cracked intake manifold gasket. It is important for GMC Savana owners to be aware of these issues and to seek professional help when needed.
Is GMC Savana reliable?
The GMC Savana 2500 Reliability Rating is 3.0 out of 5.0, which ranks it 11th out of 21 for commercial vans.
What is the life expectancy of a GMC Savana?
If you keep up with the maintenance schedule of your Savana, it can last long term, whether you use it each day or a few times a week. The longevity of a GMC Savana is around 20 years at its maximum life span.
How many miles per gallon does a GMC Savana get?
Based on data from 1 vehicles, 113 fuel-ups and 42,219 miles of driving, the 2021 GMC Savana 3500 gets a combined Avg MPG of 15.69 with a 0.70 MPG margin of error.
When did they stop making the GMC Savana?
Chevrolet Express
| Chevrolet Express GMC Savana | |
|---|---|
| Also called | GMC Savana Chevrolet Van (1996–1998; cargo van) Chevrolet Savana (Israel and the Philippines) |
| Production | January 1996–present |
| Model years | 1996–present |
| Assembly | United States: Wentzville, Missouri (Wentzville Assembly) Springfield, Ohio (Navistar) |
Percentage distribution of complaints by Gmc Savana years
We have researched Gmc problems and analysed all the complaints filed against Gmc Savana cars and compiled the top 5 most problematic Gmc Savana model years:
Below you can see the percentage distribution of known problems by Gmc Savana model years.
Distribution of the number of complaints by Gmc Savana years
We've also compiled a chart for you with the number of complaints about Volkswagen Jetta cars of certain model years:
Gmc Savana car problems categorized by type of issue
After analysing all complaints related to Gmc Savana , it was concluded that the most common issues with these cars are:
- Service brakes problems
- Hydraulic problems
- Structure problems
- Tires problems
- Engine and engine cooling problems
The graph below shows statistics for all Gmc Savana vehicle components and the number of complaints received.
Distribution of the number of complaints where the accident occurred by Savana model years
A total of 19 complaints were registered in which the accident occurred. In the graph you can see the distribution of the number of complaints by model year.
Distribution of the number of complaints with fire by Savana model years
There were a total of 12 complaints that resulted in a fire. In the graph you can see the distribution of the number of complaints by model year.
Distribution of the number of complaints with injuries by Savana model years
There were a total of 23 complaints that resulted in a injuries. In the graph you can see the distribution of the number of complaints by model year.
The NHTSA has received 369 complaints about various vehicle components related to the Gmc Savana . Below are the 25 most recent complaints reported for Gmc Savana vehicles.
Latest 25 complaints
Gmc Savana 2005
- Date Of Incident: 2022-11-12
- Date Complaint: 2023-07-17
- VIN: 1GJHG39U151
- Components: VISIBILITY
- Summary: I had a new front windshield sold by PGW installed by Coughlin Auto Glass in Deer Lodge Montana in November - December 2022. I immediately noticed that the windshield did not allow RED LIGHT to pass through the tinted area. This is most likely due to a manufacturing defect and is dangerous. Unfortunately I did not have time to argue with the installer about a replacement until now, as I have been out of the state until yesterday. The installer confirmed that the glass was defective. He states that he contacted PGW today and that they will not replace the window. He and Pittsburg Glass Works state that they have had no other complaints and that it is too late to do anything about it. I suspect there is an entire batch of glass windshields that have this manufacturing defect. The consumer representative for PGW admitted that they had problems with supplies and manufacturing during COVID. I suspect this happened due to COVID related manufacturing problems.
Gmc Savana 2005
- Date Of Incident: 2023-05-01
- Date Complaint: 2023-05-24
- VIN: 1GDHG31V051
- Components: ELECTRICAL SYSTEM,UNKNOWN OR OTHER
- Summary: We received a Safety Recall for our GMC 2005 G3500 school bus in the mail. The GM recall # is N222386050. The NHTSA Campaign ID number for this recall is 23V247. I have contacted our local dealer to resolve the recall and I was informed by the dealer that they are not sure if they can perform this type of work. I then called the Manufacturer's number on our recall letter to find out where to get this work done, I keep getting transferred to different departments only to reach voicemail boxes. Can anyone please let me know if this recall can be resolved by any nearby dealer or vehicle shop? My name is Diego, you can contact me at (914) 432-6929, and my email address is [email protected]. Attached to this complaint is the recall letter we received. I'm looking forward to hearing from someone. Thank you.
Gmc Savana 2000
- Date Of Incident: 2023-04-06
- Date Complaint: 2023-05-05
- VIN: 1GJHG39R6Y1
- Components: TIRES
- Summary: Tire size P 245/75 R 16 Was transporting church members (8) to church function on enter state when the tire blew out for no apparent reason. No more than 1000 miles ware on tires. The blow out caused damage to rear radiator causing overheating and damaging engine
Gmc Savana 2004
- Date Of Incident: 2022-10-01
- Date Complaint: 2022-11-01
- VIN: 1GDFG15T041
- Components: SERVICE BRAKES, HYDRAULIC
- Summary: The contact owns a 2004 GMC Savana. The contact stated that while driving at an undisclosed speed, the brake pedal went to the floorboard while depressed. The dealer was made aware of the failure and scheduled an upcoming appointment; however, the vehicle was not diagnosed nor repaired. The manufacturer was made aware of the failure and informed the contact that there was no recall associated with the VIN. The contact related the failure to NHTSA Campaign Number: 04V045000 (Service Brakes, Hydraulic) however, the VIN was not included in the recall. The failure mileage was approximately 92,000.
Gmc Savana 1998
- Date Of Incident: 2019-07-20
- Date Complaint: 2022-08-09
- VIN: 1GTGG25R4W1
- Components: ELECTRICAL SYSTEM
- Summary: GM theft system engaged leaving me stranded multiple times including on a remote mountain side. I was only able to get a cell signal by walking a few KM's down the road in the middle of the night to call for help. When I was able to get a hold of the dealer in the morning, they instructed me on how to "relearn" the key code and drive the van to the dealership. They cut a new key and sent me on my way. Since, the van theft system has left me stranded multiple times and me having to spend half an hour or more doing the relearn procedure. Warning lamps include "security' light illuminated on dash. Van starts, runs for 2 seconds and turns off.
Gmc Savana 2007
- Date Of Incident: 2020-11-12
- Date Complaint: 2020-11-12
- VIN: 1GTGG25V971
- Components: AIR BAGS
- Summary: THE LIGHT IS ON ,AIRBAG NOT WORKING AT THE CLUSTER
Gmc Savana 2004
- Date Of Incident: 2019-11-16
- Date Complaint: 2019-12-17
- VIN: 1GTHG35U141
- Components: WHEELS
- Summary: PROBLEM IS WITH A NEW TIRE PURCHASE BF GOODRICH LT245/75R16 BFG COMMERCIAL TA A/S2. I NOTICE FLAT SPOTTING EVERY MORNING AND IT COULD TAKE 1/2 HR OF DRIVING TO CLEAR UP BEEN DRIVING FOR OVER 60 YRS AND HAVE NEVER EXPERIENCED THIS BEFORE. I CONSIDER THIS TO BE A BAD TIRE. IF IT HAS FLAT SPOTS WITH 70PSI AND MIN. LOAD WHAT WILL HAPPEN WITH FULL LOAD. RETURNED TO DEALER BUT HE FAILS TO SEE A PROBLEM. I WAS PARKED 12HRS AND PROBLEM APPEARS EACH MORNING. I FEEL VERY UNCOMFORTABLE WITH THIS TIRE ON MY TRUCK.
Gmc Savana 2003
- Date Of Incident: 2018-10-01
- Date Complaint: 2019-05-17
- VIN: 1GTHG35U331
- Components: STEERING,SERVICE BRAKES
- Summary: TL* THE CONTACT OWNS A 2003 GMC SAVANA. WHILE OPERATING THE VEHICLE, THE STEERING WHEEL AND BRAKE PEDAL MALFUNCTIONED AND DID NOT PROPERLY OPERATE. WHILE DEPRESSING THE BRAKE PEDAL, THE STEERING WHEEL WOULD JERK AND THE BRAKE PEDAL WAS HARD TO DEPRESS, WHICH AFFECTED THE VEHICLE STOPPING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE BRAKE HYDRO PUMP WAS FAULTY. THE PUMP WAS REPLACED, BUT THE FAILURES CONTINUED. THE CONTACT INDICATED THAT THE HYDRO PUMP HAD BEEN REPLACED THREE TIMES WITHIN THE PAST EIGHT MONTHS. THE MANUFACTURER AND LOCAL DEALER WERE NOT NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 100,000.
Gmc Savana 2007
- Date Of Incident: 2017-10-04
- Date Complaint: 2017-10-27
- Number Of Injuries: 1
- Crash: 1
- VIN: 1GDFG15T861
- Components: SERVICE BRAKES
- Summary: TL* THE CONTACT OWNED A 2007 GMC SAVANA. WHILE DRIVING APPROXIMATELY 20 MPH, THE DRIVER ATTEMPTED TO STOP, BUT THE BRAKES FAILED. AS A RESULT, THE CONTACT CRASHED INTO THE PRECEDING VEHICLE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE AIR BAGS DID NOT DEPLOY. THE DRIVER SUSTAINED INJURIES THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOTALED AND WAS TOWED TO A TOW YARD. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 116,000.
Gmc Savana 2006
- Date Of Incident: 2017-04-04
- Date Complaint: 2017-04-25
- VIN: 1GDFG15T761
- Components: ENGINE
- Summary: TL* THE CONTACT OWNS A 2006 GMC SAVANA. WHILE DRIVING 50 MPH, THE VEHICLE STALLED WITHOUT WARNING. ALSO, THE VEHICLE WOULD NOT START WHEN PROMPTED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO BE DIAGNOSED, BUT THE DEALER COULD NOT DUPLICATE THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 72,000. THE VIN WAS NOT AVAILABLE...UPDATED 09/11/17 *BF
Gmc Savana 2007
- Date Of Incident: 2016-07-11
- Date Complaint: 2016-07-26
- Components: TIRES
- Summary: TL* THE CONTACT OWNS A 2007 GMC SAVANA 3500 EQUIPPED WITH COOPER DISCOVERER H/T TIRES, SIZE: LT26/75/R16 (NA). THE CONTACT STATED THAT THE TREAD LINE SEPARATED ON THE REAR DRIVER TIRE AND BOTH THE FRONT AND REAR PASSENGER TIRES. THESE WERE REPLACEMENT TIRES. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TIRES NEEDED TO BE REPLACED. THE FRONT PASSENGER AND REAR DRIVER TIRES WERE REPLACED. THE MANUFACTURER WAS INFORMED AND STATED THAT THE TIRES WERE NO LONGER COVERED UNDER WARRANTY. THE VIN AND DOT NUMBER WERE UNAVAILABLE. THE APPROXIMATE VEHICLE FAILURE MILEAGE WAS 70,000 AND THE TIRE FAILURE MILEAGE WAS 30,000.
Gmc Savana 2006
- Date Of Incident: 2016-02-24
- Date Complaint: 2016-02-24
- VIN: 1GDGG31V361
- Components: SEATS
- Summary: I OWN 6 GMC SAVANA 3500 "3" 2005 & "3" 2006 I FOUND ON LINE THAT THERE WAS A RECALL FOR SEAT BELTS FOR BOTH YEARS AND CAN NOT FIND IT ON YOUR SITE THE RECALL # IS 05113
Gmc Savana 2002
- Date Of Incident: 2015-08-19
- Date Complaint: 2015-10-28
- Components: SERVICE BRAKES, HYDRAULIC
- Summary: S10 DIRECT REPLY- LETTER TO THE SECRETARY FROM CONSTITUENT RE REQUESTING ASSISTANCE WITH THE RECALL OF A 2012 GENERAL MOTORS VEHICLE. *SMD THE CONSUMER STATED IN MARCH 2015, HE RECEIVED AN INFORMATION LETTER, NOT A RECALL THAT THE BRAKE LINE MAY FAIL DUE TO INADEQUATE CLEARANCE. AFTER VISITING THE GMC DEALER, THE CONSUMER WAS INFORMED THERE WERE NO PROBLEM INDICATORS AT THAT TIME AND THE PART WOULD NOT BE REPLACED UNTIL IT FAILED. ON AUGUST 19, 2015, WHILE DRIVING ON A STEEP MOUNTAIN ROAD WITH AN 8% GRADE, THE BRAKES FAILED. BY USING THE TRANSMISSION TO ASSIST IN BRAKING, THE CONSUMER WAS ABLE TO DRIVE THE VAN TO A FLAT AREA BEFORE AN ACCIDENT OCCURRED. ALL THE BRAKE FLUID LEAKED FROM THE RESERVOIR AND FLUID SPLASHED ON THE UNDER CARRIAGE DUE TO BRAKE LINE FAILURE. THE VEHICLE WAS TOWED TO THE DEALER. THE CONSUMER WAS INFORMED IT WOULD TAKE 6-8 DAYS TO GET THE REDESIGNED PART. THE BRAKE LINE HAD A HOLE IN IT BECAUSE IT WAS INSTALLED IN A KNOWN AREA OF INADEQUATE CLEARANCE. *JB
Gmc Savana 2003
- Date Of Incident: 2014-10-01
- Date Complaint: 2015-10-23
- VIN: 1GTEG15XX31
- Components: FUEL SYSTEM, GASOLINE
- Summary: TL* THE CONTACT OWNS A 2003 GMC SAVANA 1500. THE CONTACT STATED THAT THERE WAS A ODOR OF FUEL INSIDE THE VEHICLE. UPON INSPECTION, IT WAS DISCOVERED THAT FUEL WAS LEAKING FROM THE VEHICLE DUE TO CORROSION OF FUEL FILLER NECK. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 110,000. UPDATED 01/27/16*LJ
Gmc Savana 2002
- Date Of Incident: 2015-08-31
- Date Complaint: 2015-09-02
- VIN: 1GTGG29R221
- Components: SERVICE BRAKES
- Summary: TL* THE CONTACT OWNS A 2002 GMC SAVANA 2500. THE CONTACT STATED THAT THE BRAKE LINES FAILED WITHOUT WARNING. THE VEHICLE WAS FURTHER INSPECTED AND IT WAS NOTICED THAT THERE WAS EXTENSIVE RUST AND CORROSION PREMATURELY AND THE BRAKE LINES FRACTURED. WHILE TRAVELING APPROXIMATELY 40 MPH, THE BRAKE PEDAL TRAVELED TO THE FLOOR AND THE BRAKE FLUID RUPTURED EXCESSIVELY DUE TO THE FAILURE OF THE BRAKE LINES. THE VEHICLE WAS TOWED TO A REPAIR SHOP WHO REPLACED ALL OF THE BRAKE LINES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 165,000.
Latest 5 recalls Gmc Savana
The National Highway Traffic Safety Administration (NHTSA) has issued 120 recalls for different components of the Gmc Savana.You can explore the year of the Volkswagen Jetta you are interested in by selecting it from the list.
- Model: Gmc Savana 2019
- Report Received Date: 2023-04-06
- Manufacturer: General Motors, LLC
- Components: ELECTRICAL SYSTEM:WIRING
- Summary: General Motors, LLC (GM) is recalling certain 2003-2023 Chevrolet Express Cutaway and GMC Savana Cutaway incomplete vehicles equipped with wiring for an optional rear heating, ventilation, and air-conditioning (HVAC) system. When the HVAC blower motor circuit is left unused with exposed connectors and wiring, the circuit can corrode and overheat.
- Consequence: An overheated electrical circuit increases the risk of a fire.
- Remedy: Dealers will properly seal the rear HVAC blower motor circuits at the left side B-pillar, free of charge. Owner notification letters were mailed May 2, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GMC's number for this recall is N222386050.
- Model: Gmc Savana 2017
- Report Received Date: 2023-04-06
- Manufacturer: General Motors, LLC
- Components: ELECTRICAL SYSTEM:WIRING
- Summary: General Motors, LLC (GM) is recalling certain 2003-2023 Chevrolet Express Cutaway and GMC Savana Cutaway incomplete vehicles equipped with wiring for an optional rear heating, ventilation, and air-conditioning (HVAC) system. When the HVAC blower motor circuit is left unused with exposed connectors and wiring, the circuit can corrode and overheat.
- Consequence: An overheated electrical circuit increases the risk of a fire.
- Remedy: Dealers will properly seal the rear HVAC blower motor circuits at the left side B-pillar, free of charge. Owner notification letters were mailed May 2, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GMC's number for this recall is N222386050.
- Model: Gmc Savana 2004
- Report Received Date: 2023-04-06
- Manufacturer: General Motors, LLC
- Components: ELECTRICAL SYSTEM:WIRING
- Summary: General Motors, LLC (GM) is recalling certain 2003-2023 Chevrolet Express Cutaway and GMC Savana Cutaway incomplete vehicles equipped with wiring for an optional rear heating, ventilation, and air-conditioning (HVAC) system. When the HVAC blower motor circuit is left unused with exposed connectors and wiring, the circuit can corrode and overheat.
- Consequence: An overheated electrical circuit increases the risk of a fire.
- Remedy: Dealers will properly seal the rear HVAC blower motor circuits at the left side B-pillar, free of charge. Owner notification letters were mailed May 2, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GMC's number for this recall is N222386050.
- Model: Gmc Savana 2013
- Report Received Date: 2023-04-06
- Manufacturer: General Motors, LLC
- Components: ELECTRICAL SYSTEM:WIRING
- Summary: General Motors, LLC (GM) is recalling certain 2003-2023 Chevrolet Express Cutaway and GMC Savana Cutaway incomplete vehicles equipped with wiring for an optional rear heating, ventilation, and air-conditioning (HVAC) system. When the HVAC blower motor circuit is left unused with exposed connectors and wiring, the circuit can corrode and overheat.
- Consequence: An overheated electrical circuit increases the risk of a fire.
- Remedy: Dealers will properly seal the rear HVAC blower motor circuits at the left side B-pillar, free of charge. Owner notification letters were mailed May 2, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GMC's number for this recall is N222386050.
- Model: Gmc Savana 2014
- Report Received Date: 2023-04-06
- Manufacturer: General Motors, LLC
- Components: ELECTRICAL SYSTEM:WIRING
- Summary: General Motors, LLC (GM) is recalling certain 2003-2023 Chevrolet Express Cutaway and GMC Savana Cutaway incomplete vehicles equipped with wiring for an optional rear heating, ventilation, and air-conditioning (HVAC) system. When the HVAC blower motor circuit is left unused with exposed connectors and wiring, the circuit can corrode and overheat.
- Consequence: An overheated electrical circuit increases the risk of a fire.
- Remedy: Dealers will properly seal the rear HVAC blower motor circuits at the left side B-pillar, free of charge. Owner notification letters were mailed May 2, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GMC's number for this recall is N222386050.
Latest negative Gmc Savana car reviews
Latest positive Gmc Savana car reviews
-
Vehicle year: 2016
We have really enjoyed driving this vehicle for the last 14000 miles. It was a conversion by Cobra, nothing too fancy, but it has the best seats available. We didn't opt for a TV or mood lights, but that hasn't detracted from our experience. The fuel economy has ranged from 12.5 mpg in sub-zero city driving to 20.2 mpg on 55 mph rural roads, which we're really happy with. The only issue we've had so far is with the windshield weather stripping, which came loose while on the interstate. Thankfully, the dealer was able to make the repair, eventually. Unfortunately, GM treats the option list like all Savanna's will be plumbing trucks, so we didn't get an MP3 cd player, XM satellite controller, or trip computer. However, all of these items are available on the Yukon/Suburban, which this van is based on. It has a 5.3 V8 engine and was the same price as the Toyota Sienna, but the extra space was the deciding factor for us.
-
Vehicle year: 2003
In November 2021, I purchased a 1998 GMC 2500 Savana with the 5.7 motor. The seller mentioned that a company had taken care of it and that the motor had been rebuilt with only 90,000 miles on it. Although I wasn't given any information about what was done to the motor, it runs great and has power. The van was previously used as a cargo van/food truck and has no major dents, but the sliding side door handle and lock were missing and the back driver's side door needs to be lifted up a touch to latch properly. Despite these minor issues, it starts up every time and goes down the highway great. The gas gauge works and there is no 'Service Engine Soon' light. I did notice a slight play in the steering when going down the highway, but it stays straight and doesn't pull from side to side. Currently, the biggest issue is a ticking sound every revolution of the engine, which is hard to locate. However, I've driven the van around 1,300 miles with the ticking sound and it hasn't gotten better or worse. I've been trying to find the culprit and have checked the flywheel for cracks, the tightness of the flywheel bolts, and even removed the left valve cover to inspect the rockers. I made a YouTube video to show the process: see this: https://youtu.be/GUGiHv2Fk3U. The rockers on the left side looked really clean and there was no gunk around the cover and on the bottom.First, I will adjust my rocker bolts and then change the oil again to check for metal shavings. While the oil pan is off, I will use a small ball peen and tap the bottom of each rod to listen for any unusual sounds. This will help me identify any problems with the bearings. In the worst-case scenario, I may have to pull the engine and check everything or replace it altogether. However, sometimes it's best to leave things as they are if they're not causing any issues. I have read about some owners who have a tick/knock and continue to drive their vehicle without any problems. If you have a 1998 GMC with a ticking noise, please let me know your situation. All in all, I love the way the van drives and it's worth it to me to repair it. The body and suspension seem to still be in great shape, as well as the brakes. I hope my review has been helpful. Take care!
-
Vehicle year: 2012
Very good in snow and provides smooth acceleration. The 4 speed auto is a little whiny. If you drive up a lot of hills, get the 6.0 v8 because it is a tad stronger off the line. My family loves this van. I'm planning my vacation in Catskills and all wheel drive will be helpful
-
Vehicle year: 2009
In November 2021, I purchased a 1998 GMC 2500 Savana with the 5.7 motor. The seller mentioned that a company had taken care of it and that the motor had been rebuilt with only 90,000 miles on it. Although I wasn't given any information about what was done to the motor, it runs great and has power. The van was previously used as a cargo van/food truck and has no major dents, but the sliding side door handle and lock were missing and the back driver's side door needs to be lifted up a touch to latch properly. Despite these minor issues, it starts up every time and goes down the highway great. The gas gauge works and there is no 'Service Engine Soon' light. I did notice a slight play in the steering when going down the highway, but it stays straight and doesn't pull from side to side. Currently, the biggest issue is a ticking sound every revolution of the engine, which is hard to locate. However, I've driven the van around 1,300 miles with the ticking sound and it hasn't gotten better or worse. I've been trying to find the culprit and have checked the flywheel for cracks, the tightness of the flywheel bolts, and even removed the left valve cover to inspect the rockers. I made a YouTube video to show the process: see this: https://youtu.be/GUGiHv2Fk3U. The rockers on the left side looked really clean and there was no gunk around the cover and on the bottom.First, I will adjust my rocker bolts and then change the oil again to check for metal shavings. While the oil pan is off, I will use a small ball peen and tap the bottom of each rod to listen for any unusual sounds. This will help me identify any problems with the bearings. In the worst-case scenario, I may have to pull the engine and check everything or replace it altogether. However, sometimes it's best to leave things as they are if they're not causing any issues. I have read about some owners who have a tick/knock and continue to drive their vehicle without any problems. If you have a 1998 GMC with a ticking noise, please let me know your situation. All in all, I love the way the van drives and it's worth it to me to repair it. The body and suspension seem to still be in great shape, as well as the brakes. I hope my review has been helpful. Take care!
-
Vehicle year: 2012
I bought this van used from the previous owner who had a Cadillac Escalade. When I bought it, it had only 90,000 original miles and some aftermarket parts. It has no rust, no engine or transmission issues, and rides great!
Are you having problems with your Gmc Savana?
Lesley Gusikowski 2024-11-28
Vehicle year: 2008
I hope you're doing well! I wanted to share my experience with my Exployer conversion. While the interior looks great, I did notice that the ride quality is only fair. Additionally, at highway speeds, there is quite a bit of wind noise which can make it difficult to hold a conversation.
Jarrell Nicolas 2024-11-25
Vehicle year: 2018
Although I have always been a GM guy, this particular van has been a disappointment. The windshield cracked on the first day off the lot due to small stones, which is indicative of poor quality glass. Additionally, the AC failed within 6 months. The fuel efficiency is also subpar, with only 10mpg in the city or on the highway, and only 12mpg on the highway on one occasion. When towing my trailer, I was only able to achieve 6mpg. Overall, I would not consider purchasing this van again.
Ronaldo Durgan 2024-11-22
Vehicle year: 2005
Great vehicle for past 4 years! The AWD has worked flawlessly and is just as good as my previous 4WD vehicle with a transfer case, but much more convenient. However, I have experienced two issues. Firstly, the AC will not hold a charge for more than one season. Secondly, the side swinging door hits the front passenger door when both are open, which dents the rear door on the edge of the front door. This is a really poor design (where were the engineers???).
Amir Pacocha 2024-11-14
Vehicle year: 2018
I hope you're doing well! I noticed that you mentioned using your van to pull your fishing boat to the ocean. That sounds like a lot of fun! I was thinking that it might be helpful to have side mirrors that extend out for better visibility when backing up in tight spaces. I've seen some really nice ones on Ford pickups that might work well for your van. Some of them even retract and fold against the truck when not in use. I know you love your van, and it sounds like you have a great system for storing all your fishing gear in holders. Just lock up the van and you're ready for your next trip!
Guiseppe Crooks 2024-11-13
Vehicle year: 2005
Great for hauling kids and camping! It's also easy to haul 4x8 sheets of ply. The rear bench has plenty of room for all my stuff, even when pulling a camper trailer. However, over time, there have been some odd brake issues and all the brake lines have become rusty, resulting in a huge expense. Additionally, I've had a few electrical issues and corroded grounds that are hard to trace.