2006 Chevrolet Express problems
The Chevrolet Express (also known as the GMC Savana) is a series of full-size vans produced by General Motors since 1996. The successor to the Chevrolet G-series van, the Express is produced in passenger and cargo variants. Alongside the standard van body, the line is offered as a cutaway van chassis; the latter vehicle is a chassis cab variant developed for commercial-grade applications, including ambulances, buses, motorhomes, and small trucks.
In production for a single generation since 1995, over 2.5 million examples of the Express and the Savana have been produced. One of the longest-produced designs in American automotive history, the Express/Savana are rivaled only by the Jeep Wagoneer and Dodge Ram Van for longevity.
Since 1995, General Motors has assembled the Express and Savana at its Wentzville Assembly facility (Wentzville, Missouri). Also, since 2017, GM has sourced commercial cutaway-chassis production from Navistar through its Springfield Assembly Plant (Springfield, Ohio).
Social links
Common 2006 Chevrolet Express problems
The 2006 Chevrolet Express is prone to stereo problems, with many owners reporting issues related to the module and power connections. The primary problem is with the 12-volt power connection wire blowing out from the board, which affects the module's ability to provide 12 volts in accy as the factory does through data.
Another common problem is with the interface module, which fails to provide the necessary 12 volts when the key is on. This can be addressed by either going directly to the key switch or ordering a new module. However, this solution may lead to losing the retained accessory power.
In some cases, the problem can be resolved by disconnecting the radio from the red module wire and capping it, then hooking it up to another switched 12-volt source, such as a cigarette lighter that is not in use.
While these solutions may address the stereo problems in the 2006 Chevrolet Express, it is important to note that the module ranges in price from $20 to $180, and purchasing a new one may not necessarily solve the problem. Therefore, it is essential to diagnose the issue accurately before investing in a new module.
In addition to stereo problems, the 2006 Chevrolet Express also has issues with the fuel pump, as reported by many owners. The most reported problem is with the 1999 Chevrolet Express for fuel pump failure, with an average cost to fix of $3,000 and an average mileage of 25,000 miles.
The Express ranks 7th in reliability out of 40 Chevrolet models, with owners making 74 complaints, mostly about engine issues.
In summary, the 2006 Chevrolet Express has several common problems, including stereo issues related to the module and power connections, and fuel pump failure. It is essential to diagnose the problem accurately before investing in new parts and to consider the potential loss of retained accessory power when implementing solutions.
How long do Chevy Express engines last?
If you have a 4.3 V6 250,000 miles would be good. If you have a 4.8L, 5.3L or 6.0L V8 all are LS based engines. Those engines if cared for properly 300,000 is not uncommon. If you drive it like you stole it all the time you will be lucky to make 150,000 miles.
Are Chevy Express vans reliable?
The Chevrolet Express 1500 Reliability Rating is 3.0 out of 5.0, which ranks it 9th out of 21 for commercial vans. The average annual repair cost is $963 which means it has poor ownership costs.
How many miles does a Chevy Express get?
Gas Mileage 7/10 – Fuel economy is okay at up to 20 MPG, offering 620 miles of range out of the 31 gallon tank. Gas costs are similar to other vans, at $369 per month. Value 8/10 – The 2019 Chevrolet Express is cheaper than a lot of other full size vans with reasonable depreciation rates, making it an attractive value.
What is the recall on the Chevy Express van?
Recall # N202325160 Date: 03/18/2021 Recall: General Motors, LLC is recalling certain 2021 Chevrolet Express and GMC Savana vehicles equipped with 6.6L gasoline engines. The positive battery cable terminals may contact a fuse block assembly attachment post and cause an electrical short circuit.
Is the Chevy Express reliable?
The Chevrolet Express 3500 Reliability Rating is 2.5 out of 5.0, which ranks it 13th out of 21 for commercial vans. The average annual repair cost is $1,013 which means it has poor ownership costs. The frequency of repairs is average, but when issues do arise, they are more likely to be severe than with other models.
How long do Chevy Express engines last?
If you have a 4.3 V6 250,000 miles would be good. If you have a 4.8L, 5.3L or 6.0L V8 all are LS based engines. Those engines if cared for properly 300,000 is not uncommon. If you drive it like you stole it all the time you will be lucky to make 150,000 miles.
What engines are in the Chevy Express?
6.6L V8. Max trailering weight of up to 9,600 lbs.
What is the mpg on a 2006 Chevy Express 1500 V-6?
Find and Compare Cars
| 2006 Chevrolet Express 1500/2500 2WD | |
|---|---|
| EPA MPG | Regular Gasoline 14 combined city/highway MPG 13 city 17 highway 7.1 gals/100 miles |
| Unofficial MPG Estimates Shared by Vehicle Owners | View Estimates How can I share my MPG? |
| Vehicle Specification Data | |
| EPA Size Class | Vans, Passenger Type |
2006 Chevrolet Express car problems categorized by type of issue
After analyzing all complaints sent to the NHTSA and researching popular Chevrolet Express problems, we found that the most common problems with these 2023 model year vehicles are:
- Structure problems
- Power train problems
- Air bags problems
- Unknown or other problems
- Fuel system problems
The graph below shows statistics for all 2006 Chevrolet Express vehicle components and the number of complaints received.
2006 Chevrolet Express complaints
The NHTSA has received 16 complaints about various vehicle components related to the 2006 Chevrolet Express.
2020-11-09
UNKNOWN OR OTHER PROBLEM
- Date Of Incident: 2020-11-09
- VIN: 1GBFG15T861
- Components: UNKNOWN OR OTHER
- Summary: THE VEHICLE SECURITY LIGHT COMES ON INTERMITTENTLY FOR YEARS, I THEN CANNOT START THE VEHICLE. I HAVE REPORTED THE PROBLEM TO GM, I HAVE HAD IT TO THE CHEVROLET DEALERSHIP TWICE, WHICH COST ME OVER A THOUSAND DOLLARS FOR THEM TO REPLACE PARTS WHICH HAD NO EFFECT IN SOLVING THE PROBLEM. THE VEHICLE WILL NOT START UNTIL YOU TURN THE KEY TO THE ON POSITION, WAIT 10 MINUTES FOR THE LIGHT TO GO OUT, THEN TURN OFF THE IGNITION FOR 10 SECONDS, THEN IT WILL START. I HAVE PUT UP WITH IT FOR YEARS, BUT WHEN I AM STRANDED IN THE DEAD OF WINTER, THAT POSES A SAFETY HAZARD. YOUR REPORT WANTS TO KNOW WHEN IT HAPPENS, IT HAPPENS WITHOUT NOTICE, RHYME OR REASON, AT ANYTIME SINCE I BOUGHT IT IN 2009.
2016-08-08
SUSPENSION PROBLEM
- Date Of Incident: 2007-12-15
- VIN: 1GAGG25U861
- Components: SUSPENSION
- Summary: TL* THE CONTACT OWNS A 2006 CHEVROLET EXPRESS. WHILE DRIVING 30 MPH, THE VEHICLE VIBRATED SEVERELY AND STOPPED WHEN THE BRAKE PEDAL WAS DEPRESSED. THE FAILURE OCCURRED CONSTANTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED, BUT THE CAUSE OF THE FAILURE WAS NOT FOUND. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 40,000.
2016-07-21
POWER TRAIN,ELECTRONIC STABILITY CONTROL (ESC),ENGINE PROBLEM
- Date Of Incident: 2016-05-18
- VIN: 1GBGG29U661
- Components: POWER TRAIN,ELECTRONIC STABILITY CONTROL (ESC),ENGINE
- Summary: I BOUGHT A CHEVROLET VAN EXPRESS WITH A 6.0 V8 ENGINE A YEAR AGO WITH ONLY 37000 MILES. APPROXIMATELY 2 MONTHS AFTER PURCHASE, I BEGAN HAVING TROUBLE WITH THE ENGINE AND STABILITRAK SYSTEM IN ADDITION TO THE LOW BEAM HEADLIGHT FAILURE DETAILED BELOW SAME ACROSS THE ENTIRE V8 6.0 ENGINES PRODUCED BY CHEVROLET. THE VAN VEHICLE SHOOK VIOLENTLY STRESSING ALL THE OCCUPANTS. WHILE TRAVELING ON THE HIGHWAY MY CHECK ENGINE AND TRACTION LIGHT ILLUMINATED SIMULTANEOUSLY. I WAS ALSO ALERTED THAT "ENGINE POWER WAS REDUCED" AND MY VEHICLE SHUT DOWN TWO TIMES IN A 30 MINUTE SPAN OF TIME. NOW WITH ONLY 41,000 MILES I HAVE PARKED THE VAN UNTIL A RECALL CORRECTS THE DANGEROUS SAFETY PROBLEMS. AGAIN WHILE TRAVELING ON THE HIGHWAY MY AIR BAG SENSOR WENT OFF WITH THE CHECK ENGINE AND TRACTION LIGHT AGAIN ILLUMINATED SIMULTANEOUSLY. THE VAN VEHICLE SHOOK VIOLENTLY STRESSING ALL THE OCCUPANTS. I WAS ALERTED THAT "ENGINE POWER WAS REDUCED" AND MY VEHICLE STOPPED COLD. I WILL NEVER BUY ANOTHER GM PRODUCT THEY ARE FRAUGHT WITH ELECTRICAL PROBLEMS. THIS IS CAUSING SAFETY ISSUES BEING IN A COMPROMISING POSITION 3 TIMES WITH 9 PEOPLE AND 2 ARE INFANTS IN THE VAN. RESEARCH SHOWS THIS TO BE AN ONGOING ISSUE. THIS HAS BEEN A NIGHTMARE. SOMETHING AS DRAMATIC AS A TOTAL ENGINE FAILURE IN A CAR THAT IS AS POPULAR AS THE V8 6.0 ENGINE IS A FRIGHTENING ISSUE THAT EVERYONE ACROSS THE INDUSTRY IS GOING TO WANT TO KNOW MORE ABOUT. F THE ENGINE WON'T RESTART . TTHE STEERING WILL FEEL INCREASINGLY HEAVIER, MAKING IT HARDER TO STEER. ALSO THE POWER BOOST FOR THE BRAKES DISAPPEARS AFTER ONE OR TWO APPLICATIONS, MAKING THE VAN HARDER TO STOP. IN THE AFFECTED VEHICLES, THE UNDERHOOD BUSSED ELECTRICAL CENTER (UBEC) HOUSING CAN EXPAND AND CAUSE THE HEADLAMP LOW BEAM RELAY CONTROL CIRCUIT WIRE TO BEND. IF THE WIRE IS REPEATEDLY BENT, IT MAY FRACTURE CAUSING A LOSS OF LOW BEAM HEADLAMP ILLUMINATION.
2014-09-12
ELECTRICAL SYSTEM PROBLEM
- Date Of Incident: 2012-12-01
- VIN: 1GBFG15T661
- Components: ELECTRICAL SYSTEM
- Summary: TL* THE CONTACT OWNS A 2006 CHEVROLET EXPRESS. WHILE DRIVING 50 MPH, THE VEHICLE JERKED AND STALLED. THE VEHICLE WOULD NOT RESTART AND WAS TOWED TO THE DEALER. THE TECHNICIAN STATED THAT THE IGNITION NEEDED TO BE REPAIRED. THE IGNITION WAS ORIGINALLY REPAIRED AT 54,322 MILES. THE VEHICLE WAS REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 70,000.
2014-05-21
AIR BAGS PROBLEM
- Date Of Incident: 2010-05-31
- VIN: 1GNFH15T161
- Components: AIR BAGS
- Summary: MY FRONT PASSENGER AIRBAG SEAT SENSOR IS NOT FUNCTIONING. IT WILL NOT TURN ON AT ALL WHEN PEOPLE OF ALL DIFFERENT SIZES ARE IN THE SEAT. IF AN ACCIDENT WERE TO HAPPEN THE AIRBAG WOULD NOT DEPLOY. *TR
2012-06-02
STRUCTURE PROBLEM
- Date Of Incident: 2010-07-01
- VIN: 1GBJG312161
- Components: STRUCTURE
- Summary: SUMMER TIME NOTICED ALUMINUM CORNER PANELS STARTED TO BUCKLE OR FLARE OUT FROM THE BOTTOMS THOUGHT IT POSSIBLY GOT HIT BYE A TRAILER BUT AS TIME WENT ON THEY FLARED OUT EVEN MORE THEN IN 2011 THEY STARTED PEELING OFF ON ONE SIDE ON EACH CORNER SO WE CONTACTED OUR DEALERSHIP WITH THE PROBLEM IN WITCH THEY TOLD US IT WAS RECALLED FOR THAT REASON THEIR WAS NO RIVETS IN THE CORNER PANELS SO THEY WOULD FALL OFF. SO WE CONTACTED SPARTAN SUPREME CORP WHO MADE THE BOX AND WAS TO WARRANTY THE BOX WHO CLAIMED OUR WARRANTY WAS UP. SO WE WENT DOWN BOUGHT PARTS SENT PICTURES AND WAS GOING TO FIX IT OUR SELVES. BUT AT LOOKING AT FIXING IT HAD GOTTEN SO BAD THAT THE CORNERS WAS NO LONGER STRAIGHT THE ENTIRE BOX IS SHIFTED AND IS BOWING OUT ON THE SIDES WITH JARRED SIDE PANEL SORS WHICH ARE RUBBING WHEN U SHUT THEM AND LOOKS UNREPAIRABLE. WE THEN CALLED AGAIN TO SPARTAN AND THEY TOLD ME IT WOULD HAVE BEEN UNDER WARRANTY WHEN WE CALLED THE FIRST TIME (EARLY 2011) AND NOW IT'S OUT OF WARRANT (LATE 2011). SO AT THIS POINT WE HAVE A BOX TRUCK WITH ON MISSING CORNER PANEL WHICH BLEW OFF SOMEWHERE OFF DOWN THE ROAD AND A LEANING BOX WITH WHICH COULD FALL APART AT ANYTIME. *TR
2011-12-29
AIR BAGS PROBLEM
- Date Of Incident: 2011-04-29
- Number Of Injuries: 2
- Crash: 1
- VIN: 1GCFG15X261
- Components: AIR BAGS
- Summary: ON APRIL 29, 2011, A PASSENGER AND I WERE INVOLVED IN A VERY SERIOUS NEAR-FATAL MOTOR VEHICLE ACCIDENT. I WAS THE DRIVER OF THE VEHICLE, WHICH WAS A 2006 CHEVY EXPRESS CARGO VAN. WE WERE DRIVING FROM MEDFORD, OREGON TO KLAMATH FALLS, OREGON ON HWY 140 EAST. THE ACCIDENT OCCURRED NEAR MILE MARKER 59 AT APPROXIMATELY 8 A.M. THIS STRETCH OF HIGHWAY RUNS PARALLEL TO KLAMATH LAKE. THE VEHICLE SPUN OUT OF CONTROL WHEN WE DROVE OVER A PATCH OF UNSEEN BLACK ICE. AS THE VEHICLE SPUN OUT OF CONTROL WE WENT ACROSS THE HIGHWAY AND INTO THE LAKE WHERE WE COLLIDED HEAD ON INTO A HUGE BOLDER (NOT A ROCK) THAT WAS PROTRUDING FROM THE WATER. THE IMPACT CAUSED THE VEHICLE TO ROLL OVER LENGTH WISE AND THEN CAME TO REST UPRIGHT IN THE WATER. THE VAN SANK INTO THE WATER AND STOPPED SINKING WHEN THE WATER LEVEL HAD RISEN TO OUR CHINS. HIGHWAY PATROL AND AN AMBULANCE TEAM WERE DISPATCHED TO THE SCENE AND IT WAS NOTED THAT THE DUAL AIRBAG SYSTEM DID NOT DEPLOY. AS A RESULT I SUSTAINED SERIOUS INJURIES INCLUDING A FRACTURED STERNUM AND A VERY SERIOUS SHOULDER INJURY WHICH REQUIRED RECONSTRUCTIVE SURGERY AND A LENGTHY RECOVERY PERIOD. MY PASSENGER SUSTAINED MINOR INJURIES. I BELIEVE, AS WELL AS OTHERS, THAT HAD THE AIRBAGS DEPLOYED, AS THEY SHOULD HAVE, THE INJURIES I RECEIVED WOULD NOT HAVE OCCURRED OR WOULD HAVE BEEN GREATLY MINIMIZED. *KB
2011-11-07
SERVICE BRAKES, HYDRAULIC PROBLEM
- Date Of Incident: 2010-11-25
- VIN: 1GCGG25V961
- Components: SERVICE BRAKES, HYDRAULIC
- Summary: THE ABS BRAKING SYSTEM ACTIVATES FOR NO REASON AND GREATLY EXTENDS THE STOPPING DISTANCE. THIS HAS PUT OUR DRIVERS IN VERY DANGEROUS SITUATIONS. WE HAVE SEVERAL GM LIGHT DUTY VANS AND TRUCKS AND THIS HAS BEEN A PROBLEM WITH ALMOST ALL OF THEM. THE WHEEL SENSOR MECHANISM IS A FAULTY DESIGN AND CAUSES A VERY DANGEROUS SITUATION FOR THE DRIVERS. GM SHOULD RECALL AND REPLACE ALL OF THESE WITH A NEWLY DESIGNED UNIT THAT WORK SAFELY. *TR
2011-10-11
STRUCTURE PROBLEM
- Date Of Incident: 2011-09-06
- VIN: 1GCGG25V461
- Components: STRUCTURE
- Summary: I HAVE ALSO EXPERIENCED PROBLEMS WITH BOTH THE PASSENGER AND DRIVERS SIDE CARGO DOOR HINGES NOT OPERATING PROPERLY AND BINDING. THIS PROBLEM WITH THE HINGES HAS OCCURRED DESPITE OUR EFFORTS TO KEEP THE HINGES LUBRICATED TO TRY TO PREVENT THE DOORS FROM BINDING SO BADLY THAT IT MADE OPENING THE DOORS ALMOST IMPOSSIBLE EVEN FOR A STRONG, GROWN MAN. I HAD TO HAVE BOTH OF THESE PROBLEMS ADDRESSED BY EITHER THE HANDICAPPED VEHICLE CONVERSION COMPANY OR THORNTON CHEVROLET ON THOSE OCCASIONS WHEN THESE PROBLEMS BECAME SO SEVERE THAT THEY PREVENTED MY UTILIZATION OF THE VEHICLE. THE MOST RECENT OCCURRENCE OF PROBLEMS WITH THE HINGES TOOK PLACE ON SEPTEMBER 6, 2011. I CONTACTED THE COLLISION REPAIR SHOP AT THORNTON CHEVROLET AND HAD THEM ATTEMPT TO CORRECT THE ISSUE BY REPLACING THE HINGE PIN ASSEMBLY ON THE PROBLEM DOOR ON THE PASSENGER SIDE (WHERE MY WHEELCHAIR LIFT IS INSTALLED AND USED TO ALLOW ME TO ENTER AND EXIT THE VEHICLE). HOWEVER, THE TRAINED COLLISION REPAIR SPECIALISTS AT THORNTON CHEVROLET REALIZED THAT THE PROBLEM WAS MORE SERIOUS THAN THIS AND INFORMED ME THAT THE ENTIRE LOWER HINGE ASSEMBLY ON THE REAR PASSENGER CARGO DOOR NEEDED TO BE REPLACED BECAUSE OF A CRACK IN THE METAL OF THE HINGE ASSEMBLY WHERE IT IS WELDED TO THE VEHICLE. AS YOU WILL REALIZE, THIS COULD HAVE BEEN AN EXTREMELY SERIOUS SAFETY PROBLEM HAD I NOT BEEN OUTSIDE OF THE VEHICLE ON THE THREE SEPARATE INSTANCES WHEN THE LATCH MECHANISM FAILED TO OPERATE PROPERLY. HAD I BEEN INSIDE THE VEHICLE OR NOT AT MY RESIDENCE (SUCH AS BEING AT MY PLACE OF EMPLOYMENT) WHEN THIS OCCURRED, I WOULD HAVE BEEN TRAPPED INSIDE THE VEHICLE. *KB
2010-02-25
ENGINE AND ENGINE COOLING,POWER TRAIN PROBLEM
- Date Of Incident: 2009-09-10
- VIN: 1GCGG29V461
- Components: ENGINE AND ENGINE COOLING,POWER TRAIN
- Summary: PURCHASED ANOTHER FLY WHEEL. *DT THE CONSUMER WAS INFORMED THERE WAS NOTHING WRONG WITH THE REDESIGNED FLYWHEEL AND THERE MUST BE ANOTHER REASON FOR IT WEARING OUT. THE CONSUMER TOOK THE VEHICLE TO ANOTHER MECHANIC FOR A SECOND OPINION AND WAS TOLD THE ORIGINAL FLYWHEELS WERE MADE STRONGER AND HAD DIFFERENT HOLES IN THEM. THE REDESIGNED FLYWHEEL WAS MUCH THINNER AND LESS EXPENSIVE. *JB
2009-11-17
FUEL SYSTEM, OTHER PROBLEM
- Date Of Incident: 2009-08-15
- Components: FUEL SYSTEM, OTHER
- Summary: FAULTY FUEL GAUGE SENSOR ON 2006 CHEVY EXPRESS VAN. MY FUEL GAUGE READ APPROX 1/8TH OF A TANK. THE LOW FUEL LIGHT HAD NOT COME ON. THE VAN STOPPED RUNNING AND COULD NOT BE STARTED. IT WAS TOWED TO NUCAR IN NEW CASTLE. SENSOR AND FUEL PUMP WERE REPLACED AS THE DEALER SAID THEY WOULD NOT GUARANTEE THE SENSOR WITHOUT REPLACING THE FUEL PUMP. THE COST > $1,000. I READ YOUR ARTICLE AND NOW FRIENDS OF MINE HAVE EXPERIENCED SIMILAR PROBLEMS. *TR
2009-10-04
STRUCTURE,LATCHES/LOCKS/LINKAGES PROBLEM
- Date Of Incident: 2009-04-13
- VIN: 1GNFG15T061
- Components: STRUCTURE,LATCHES/LOCKS/LINKAGES
- Summary: THE HINGES ON THE DOORS OF CHEVY VANS ARE DEFECTIVE IN THAT THEY ARE IMPROPERLY DESIGNED AND CORRODED AND BECOME DIFFICULT IF NOT IMPOSSIBLE TO OPEN AND CLOSE THE HINGES ARE INVERTED AND ALLOW DIRT AND WATER TO INVADE THE SWIVEL PORTION OF THE HINGE I HAVE REPORTED THIS TO THE DEALERS ARE THREE OCCASIONS AND THEY BASICALLY SAID TUFF LUCK THEY WERE AWARE OF THE PROBLEM WHEN I WENT IN THEY SAY ADDITIONAL MAINTENANCE IS REQUIRED BUT MAKE NO MENTION OF IT NOR DO THEY DO ANYTHING SPECIAL AT THEIR FACILITY I HAVE HAD MY VEHICLES SERVICED THERE AND IT MAKES NO DIFFERENCE. *TR
2009-09-16
UNKNOWN OR OTHER PROBLEM
- Date Of Incident: 2009-08-12
- VIN: 1GBHG31UX61
- Components: UNKNOWN OR OTHER
- Summary: I AM WRITING TO FILE A COMPLAINT AGAINST SUPREME CORPORATION 2581 EAST KERCHER RD. GOSHEN, IN 46527. I RECEIVED A SAFETY RECALL NOTICE FROM THEM DATED AUGUST 12, 2009 WHICH INDICATED A DEFECT IN CERTAIN SPARTAN SERVICE AND CARGO BODIES MANUFACTURED BETWEEN JANUARY 2006 TO JUNE 2008. I OWN A 2006 VEHICLE WITH A SPARTAN CARGO BODY. THE RECALL APPLIES TO A POTENTIAL DEFECT IN THE BONDING OF THE ROOF SKIN TO ROOF RAIL EXTRUSION AND ROOF RAIL EXTRUSION TO SIDE WALL AND INDICATES THAT WHILE THE VEHICLE IS IN OPERATION PARTS OF THE ROOF SKIN OR ROOF ITSELF COULD DELAMINATE OR DISLODGE. THE RECALL FURTHER STATES THE POTENTIAL FOR DEATH OR SERIOUS INJURY EXISTS TO OTHER VEHICLES OR THE GENERAL PUBLIC SHOULD ANY PART OF THE ROOF BECOME UNBONDED. THE RECALL STATES THAT THERE IS AN ATTACHED LIST OF SHOPS APPROVED BY SUPREME CORPORATION TO PERFORM THE RECALL REPAIR, HOWEVER NO LIST WAS ATTACHED. FURTHER, I CONTACTED SUPREME CORPORATION AT 800-557-2785 FOUR TIMES AND REQUESTED THE LIST OF REPAIR SHOPS. I WAS TOLD ON FOUR OCCASIONS THAT THE LIST WOULD BE EMAILED TO ME. I NEVER RECEIVED ANY EMAILS OR OTHER COMMUNICATION FROM SUPREME CORPORATION. SUPREME CORPORATION IS BEING NEGLIGENT AND IRRESPONSIBLE IN THE MATTER. *TR
2009-01-11
FUEL SYSTEM, GASOLINE PROBLEM
- Date Of Incident: 2009-01-10
- VIN: 1GCFG15X161
- Components: FUEL SYSTEM, GASOLINE
- Summary: DRIVING ALONG THE HIGHWAY, MY WARNING LIGHT CAME ON STATING THERE WAS AN ENGINE PROBLEM. I WAITED TO GET IT CHECKED OUT. AS I WAS MAKING A DELIVERY THE 2006 EXPRESS CARGO STALLED ON THE HIGHWAY. HAD IT TOWED TO THE CHEVROLET DEALERSHIP AND THEY STATED IT WAS THE FUEL SENSOR IN THE GAS TANK THAT BURNT OUT. *TR
2006-09-21
SEAT BELTS,SEATS PROBLEM
- Date Of Incident: 2006-09-21
- Components: SEAT BELTS,SEATS
- Summary: 2006 CHEVROLET EXPRESS 15 PASSENGER VAN THE VAN IS EQUIPPED WITH 4 BENCH SEATS. THE FIRST THREE BENCHES SEAT THREE PEOPLE AND THE LAST BACK BENCH SEATS FOUR. THIS LEAVES A VERY SMALL WALKWAY TO ACCESS THE SEATS FROM THE DOOR. THE SEAT BELTS FOR THE OUTER POSITIONS OF THE BENCH SEATS ARE AFFIXED TO THE SIDE WALLS PROVIDING SHOULDER BELTS FOR THESE SEATS. THESE BELTS HAVE TWO BUCKLE ENDS ON EACH BELT. THE CLIP ON THE END OF THE BELT SPANS THE WALKWAY AND ATTACHES TO THE WALKWAY SIDE OF THE BENCH SEAT. THE OTHER SLIDING CONNECTOR THEN IS ATTACHED TO THE OTHER SIDE OF THE OCCUPANT PROVIDING A SHOULDER AND LAP RESTRAINT. ONCE CONNECTED, THIS BUCKLE IS NOT INTENDED TO BE REMOVED IT LACKS A USABLE BUTTON TO DISCONNECT THE BELT. IT DOES HAVE A SMALL RECTANGULAR HOLE IN THE FRONT TO STICK IN AN OBJECT, FLAT SCREWDRIVER, OR SUCH TO DISCONNECT THE BELT. WITH THIS CONFIGURATION THE OCCUPANTS OF THE FRONT BENCH CAN ENTER OR EXIT THE VEHICLE WITHOUT BEING IMPEDED. THE OCCUPANTS OF THE REMAINING SEATS ARE FORCED TO TRANSVERSE THE BELTS OF THE SEATS IN FRONT OF IT AS THEY ENTER OR EXIT THE VEHICLE. THIS CONFIGURATION PRODUCES A STRANGULATION HAZARD FOR 10 OF THE 15 OCCUPANTS IN THE REAR OF THE VEHICLE AS THEY ENTER OR EXIT THE VEHICLE. THIS PROBLEM CAN BE COMPOUNDED IN AN ACCIDENT SITUATION. *JB
2006-05-21
STEERING PROBLEM
- Date Of Incident: 2006-04-25
- Crash: 1
- Components: STEERING
- Summary: I WAS LEAVING A MILITARY HOSPITAL AFTER DROPPING OFF MILITARY PEOPLE AND TURNED LEFT AND DROVE ABOUT 200 YARDS WHEN SOMETHING HAPPENED TO THE STEERING AND I COULDN'T STEER THE VEHICLE AND THE VEHICLE WENT TO THE RIGHT HITTING A ROAD SIDE LIGHT POLE. THE RIGHT FRONT TIRE WAS BLOWN ON THE INSIDE SIDEWALL. I CAN'T SAY THAT IT HAD BLOWN BEFORE OR AFTER THE CRASH. *NM
2006 Chevrolet Express recalls
The National Highway Traffic Safety Administration (NHTSA) has issued 16 recalls for different components of the 2006 Chevrolet Express.
2009-07-29
- Manufacturer: VAN PRODUCTS MOBILITY & COMMERCIAL
- Components: EQUIPMENT ADAPTIVE/MOBILITY
- Summary: VAN PRODUCTS IS RECALLING 8 VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THE LIFT FAILS TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS ON MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.
- Consequence: THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
- Remedy: VAN PRODUCTS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFT FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000.
2009-07-29
- Manufacturer: THE CUSTOMIZERS INC.
- Components: EQUIPMENT ADAPTIVE/MOBILITY
- Summary: CUSTOMIZERS IS RECALLING 6 VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS ON MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.
- Consequence: THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
- Remedy: CUSTOMIZERS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFT FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000.
2009-07-29
- Manufacturer: VAN PRODUCTS MOBILITY & COMMERCIAL
- Components: EQUIPMENT ADAPTIVE/MOBILITY
- Summary: VAN PRODUCTS IS RECALLING 8 VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEM ACCESSIBLE FOR MOTOR VEHICLES," THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.
- Consequence: A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.
- Remedy: VAN PRODUCTS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000.
2009-07-06
- Manufacturer: MAIN MOBILITY, INC.
- Components: EQUIPMENT ADAPTIVE/MOBILITY
- Summary: MAIN MOBILITY IS RECALLING 185 MODEL YEAR 2005 THROUGH 2009 CHEVROLET EXPRESS AND GMC SAVANA VANS MANUFACTURED BETWEEN APRIL 1, 2005 AND JUNE 25, 2009, EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.
- Consequence: THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
- Remedy: MAIN MOBILITY IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MAIN MOBILITY AT 1-716-759-6811.
2009-07-06
- Manufacturer: MAIN MOBILITY, INC.
- Components: EQUIPMENT ADAPTIVE/MOBILITY
- Summary: MAIN MOBILITY IS RECALLING 185 MODEL YEAR 2005 THROUGH 2009 CHEVROLET EXPRESS AND GMC SAVANA VANS MANUFACTURED BETWEEN APRIL 1, 2005 AND JUNE 25, 2009, EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.
- Consequence: THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
- Remedy: MAIN MOBILITY IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MAIN MOBILITY AT 1-716-759-6811.
2009-02-06
- Manufacturer: MOBILITY SPECIALIST INC
- Components: EQUIPMENT ADAPTIVE/MOBILITY
- Summary: MOBILITY IS RECALLING 43 MY 2005-2006 FORD E-SERIES AND CHEVROLET EXPRESS VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEM ACCESSIBLE FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.
- Consequence: A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.
- Remedy: MOBILITY IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MOBILITY AT 714-674-0480.
2009-02-06
- Manufacturer: MOBILITY SPECIALIST INC
- Components: EQUIPMENT ADAPTIVE/MOBILITY
- Summary: MOBILITY IS RECALLING 86 MY 2005-2006 FORD E-SERIES AND CHEVROLET EXPRESS VAN EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS ON MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.
- Consequence: THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
- Remedy: MOBILITY IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MOBILITY AT 714-674-0480.
2009-01-28
- Manufacturer: OBS, INC.
- Components: EQUIPMENT ADAPTIVE/MOBILITY
- Summary: OBS IS RECALLING 3 RICON WHEELCHAIR LIFTS WHICH IT INSTALLED ON MY 2006 BLUE BIRD AND CHEVROLET EXPRESS SCHOOL BUSES. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.
- Consequence: THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
- Remedy: OBS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR OBS AT 1-330-453-3725.
2008-10-24
- Manufacturer: CUMMINGS MOBILITY CONVERSION & SUPPLY, I
- Components: EQUIPMENT ADAPTIVE/MOBILITY
- Summary: CUMMINGS IS RECALLING 42 MY 2006-2008 FORD E150, E350, CHEVROLET EXPRESS, MY 2006 FORD E250, GMC SAVANNA, DODGE SPRINTER CONVERSION VANS, AND MY 2007 NEWMAR DUTCHSTAR MOTOR HOMES EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.
- Consequence: A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.
- Remedy: CUMMINGS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR CUMMINGS AT 1-763-498-7887.
2008-10-24
- Manufacturer: CUMMINGS MOBILITY CONVERSION & SUPPLY, I
- Components: EQUIPMENT ADAPTIVE/MOBILITY
- Summary: CUMMINGS IS RECALLING 42 MY 2006-2008 FORD E150, E350, CHEVROLET EXPRESS, MY 2006 FORD E250, GMC SAVANNA, DODGE SPRINTER CONVERSION VANS, AND MY 2007 NEWMAR DUTCHSTAR MOTOR HOMES EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATION IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.
- Consequence: THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
- Remedy: CUMMINGS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR CUMMINGS AT 1-763-498-7887.
2008-09-22
- Manufacturer: QUALITY VAN SALES, INC.
- Components: EQUIPMENT ADAPTIVE/MOBILITY
- Summary: QUALITY VAN SALES IS RECALLING 18 MY 2005-2007 FORD E-250, MY 2006 FORD E-350 AND CHEVROLET EXPRESS VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.
- Consequence: A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.
- Remedy: QUALITY VAN SALES IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR QUALITY VAN SALES AT 1-800-408-8550.
2008-09-22
- Manufacturer: QUALITY VAN SALES, INC.
- Components: EQUIPMENT ADAPTIVE/MOBILITY
- Summary: QUALITY VAN SALES IS RECALLING 18 MY 2005-2007 FORD E-250, MY 2006 FORD E-350, AND CHEVROLET EXPRESS VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.
- Consequence: THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
- Remedy: QUALITY VAN SALES IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR QUALITY VAN SALES AT 1-800-408-8550.
2008-04-15
- Manufacturer: GENERAL MOTORS CORP.
- Components: SEAT BELTS
- Summary: GM IS RECALLING 4,003 MY 2006 CHEVROLET EXPRESS AND GMC SAVANA FULL-SIZE PASSENGER, CARGO, OR CUTAWAY VANS. THE FRONT AND REAR SEAT BELT BUCKLES WILL NOT LATCH OR WILL NOT UNLATCH.
- Consequence: IN THE EVENT OF A CRASH, A SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.
- Remedy: DEALERS WILL INSPECT THE BUCKLES AND, IF FOUND TO BE INOPERATIVE, THE ENTIRE BUCKLE ASSEMBLY WOULD BE REPLACED. FOR BUCKLES FOUND TO BE OPERATIVE, DEALER WILL REPLACE ONLY THE UPPER BUCKLE COVER. THE RECALL BEGAN ON APRIL 30, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463, OR THROUGH THEIR WEBSITE AT HTTP://WWW.GMOWNERCENTER.COM . NOTE: THIS CAMPAIGN IS AN EXPANSION OF A PREVIOUS RECALL (PLEASE SEE 05V558).
2005-12-19
- Manufacturer: GENERAL MOTORS CORP.
- Components: SEAT BELTS
- Summary: ON CERTAIN FULL-SIZE PASSENGER, CARGO, OR CUTAWAY VANS, THE FRONT AND REAR SEAT BELT BUCKLES WILL NOT LATCH OR WILL NOT UNLATCH.
- Consequence: IN THE EVENT OF A CRASH, A SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.
- Remedy: DEALERS WILL INSPECT THE BUCKLES AND, IF FOUND TO BE INOPERATIVE, THE ENTIRE BUCKLE ASSEMBLY WOULD BE REPLACED. FOR BUCKLES FOUND TO BE OPERATIVE, DEALER WILL REPLACE ONLY THE UPPER BUCKLE COVER. THE RECALL WILL BE CONDUCTED IN PHASES. THE FIRST PHASE MAILING BEGAN DURING MARCH 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
2005-12-07
- Manufacturer: GENERAL MOTORS CORP.
- Components: EQUIPMENT:OTHER:LABELS
- Summary: CERTAIN TRUCKS AND SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SHIPPED WITH TIRE AND LOADING INFORMATION LABELS LISTING AN INACCCURATE VEHICLE CAPACITY WEIGHT.
- Consequence: A MISPRINTED LABEL COULD LEAD TO IMPROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.
- Remedy: OWNERS WILL BE PROVIDED WITH CORRECTED LABELS AND INSTALLATION INSTRUCTIONS. AT THE CUSTOMER'S OPTION, A DEALER CAN INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON MARCH 31, 2006. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, HUMMER AT 1-800-732-5493, PONTIAC AT 1-800-620-7668, SATURN AT 1-800-972-8876, OR ISUZU AT 1-800-255-6727.
2005-10-05
- Manufacturer: GENERAL MOTORS CORP.
- Components: STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
- Summary: CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION. UNDER EXTREME STEERING MANEUVERS, SUCH AS TURNING THE STEERING WHEEL FULLY TO THE LEFT OR RIGHT WHILE BRAKING, THE HOSE MAY FRACTURE AND LEAK FLUID.
- Consequence: IF THIS WERE TO OCCUR, POWER STEERING ASSIST WOULD BE LOST AND INCREASED STEERING EFFORT WOULD BE REQUIRED. ON VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, IT COULD ALSO RESULT IN LOSS OF POWER BRAKE ASSIST AND INCREASED BRAKING EFFORT WOULD BE REQUIRED. IF THE POWER STEERING FLUID SPRAY WERE TO SPRAY ONTO HOT ENGINE PARTS, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
- Remedy: DEALERS WILL INSPECT THE POWER STEERING HOSE(S) FOR TWO SUSPECT DATE CODES AND REPLACE THEM IF REQUIRED. THE RECALL WILL BEGIN ON OCTOBER 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, ISUZU AT 1-800-255-6727, OR HUMMER AT 1-800-732-5493.
Negative 2006 Chevrolet Express car reviews
Positive 2006 Chevrolet Express car reviews
-
We're driving our second customized Chevy 1500 van and we absolutely love it! This one is a 2004 and it's still running like a charm, so we haven't even considered letting it go yet. It's incredibly comfortable and has given us plenty of room for several college move-ins. The only downside we've experienced is that both vans have needed transmission replacements. But overall, we highly recommend this van - it's like a beloved family member!
-
Change the oil and keep up with the maintenance. With 226k on it, we would still drive it from Delaware to Florida today! Our car has been so good to us that we are upgrading and still keeping it as a backup.
-
I hope you're doing well! I just wanted to share that I bought this van used for my plumbing business and I'm really happy with it. The AWD is incredible in the snow, even better than any of the 4x4 trucks I've had in the past. It rides great, gets decent gas mileage at 14-15 MPG, and drives really nicely. The only thing I wish is that it came in an extended version. Thanks for listening!
-
Great for hauling kids, dogs, and everything. Also, the 300hp is great for pulling our 31 ft. 7800 lb. camper. It looks tough too.
-
This is a great vehicle for families and offers good value when compared to a Suburban. Even with the 4.3L V6, it performs well, although the available V8 would probably be even better. The locking rear axle makes winter driving very manageable, and the optional 4-wheel disk brakes are a welcome addition to stop this 5300lb truck.
Additional sources
More sources of information about 2006 Chevrolet Express problems:
Chevrolet Express 2500 Problems and Complaints - 21 Issues
https://repairpal.com/problems/chevrolet/express-2500
Top Chevrolet Express 2500 Problems · Fuel Level Sensor Failure · Tail Light Wiring in Cargo Area May be Damaged · Electrical components under front carpet may be ...
Q&A: Common Problems with 2003 Chevy Express 3500 Van
https://www.justanswer.com/chevy/1ifq6-2003-chevy-express-3500-van-i-m-having-problems.html
Oct 21, 2008 ... Poor connection at PCM or IAC motor. Inspect harness connectors for backed out terminals, improper mating, broken locks, improperly formed or ...
2006 Chevrolet Express 3500 Problems and Complaints - 14 Issues
https://repairpal.com/2006-chevrolet-express-3500/problems
Top 2006 Chevrolet Express 3500 Problems · Tail Light Wiring in Cargo Area May be Damaged · Fuel Level Sensor Failure · Electrical components under front carpet ...
Q&A: Common Problems with 03 Chevy Express 3500 & 6.0L Engine
https://www.justanswer.com/chevy/8cp9b-03-chevy-express-3500-6-0l-engine-stalls-intermittently-no.html
Mar 22, 2014 ... 03 chevy express 3500 6.0l. engine stalls intermittently, no codes other than evap leak. Changed fuel filter, dropped - Answered by a ...
2006 Chevrolet Express 1500 Problems and Complaints - 12 Issues
https://repairpal.com/2006-chevrolet-express-1500/problems
Problem with your 2006 Chevrolet Express 1500? Our list of 12 known complaints reported by owners can help you fix your 2006 Chevrolet Express 1500.
Other years of Chevrolet Express
Are you having problems with your 2006 Chevrolet Express?
Mario Lockman 2024-11-06
Hope you'll find this useful for both business and pleasure. I might add a few personal touches to make it even better!
Keyon Veum 2024-10-02
We bought the van because we outgrew our Grand Caravan, and we absolutely love the fact that we can tow anything we want. I've only owned it for three months, but I already love the room and power it provides.
Darryl Gibson 2024-08-16
While the engine and transmission of these vehicles are superior to those of Fords, the rest of the vehicle falls short. The old 1975-1992 Econoline has more room, feels better, drives better, handles better, and has a more solid body. The interior of the Express is uncomfortable and made of hard plastic that creaks and feels like it might break. The front seating is cramped and less roomy than Ford. The ride is not very smooth and can be a bit rough. The sliding door rattles and shakes when closed gently. All doors, controls, seats, and dash feel cheap compared to Ford. However, we understand that everyone has different preferences and priorities when it comes to choosing a vehicle.
Antwan Rodriguez 2024-05-08
Our family van is our second express. The first one was a 1999 12-passenger van, and the current one is a 2011 15-passenger van. We have no reason to sell it other than the fact that it's a little old to take on cross-country trips. It's great for local trips to Lowe's with the seats out or for family events with all or some of the seats back in. We drive it every day, but we don't want to pay the sticker price of a new one since they really haven't changed much over the years.
Kraig Rippin 2024-01-14
This is a fantastic van!