2008 Ford F-650 sd problems
The medium-duty version of the Ford F-Series is a range of commercial trucks manufactured by Ford Motor Company since 1948. Derived from the smaller F-Series pickup trucks, the medium-duty range is currently in its eighth generation. Initially slotted between the F-Series pickup trucks and the "Big Job" conventionals, later generations were slotted below the L-Series "Louisville" trucks; the last two generations are the largest vehicles produced by Ford since its exit from the heavy-truck segment.
The medium-duty F-Series has been used for an extensive number of applications, offered as a straight (rigid) truck and a truck-tractor (for semitrailers) in multiple cab configurations. Prior to the production of the Ford C-Series, the model line was also offered in a cab-over engine (COE) configuration; a cowled-chassis variant (the Ford B-series) was used for bus production.
For the 2000 model year, the medium-duty F-Series has been branded as part of the Ford Super Duty range, consisting of the Class 6–7 Ford F-650 and F-750; Class 8 versions of the F-750 have been produced since 2011. The current generation of the medium-duty F-Series is manufactured by Ford in its Ohio Assembly facility (Avon Lake, Ohio), replacing a joint venture with Navistar International named Blue Diamond Truck Company LLC located in General Escobedo, Mexico.
Social links
Common 2008 Ford F-650 sd problems
The 2008 Ford F-650 SD is known to have several common problems, primarily related to the engine, transmission, and electrical system. These issues have been reported by owners and documented in recalls.
- Fuel System Issues: The 2008 Ford F-650 SD's fuel system has been reported to have problems with water and debris in the diesel fuel, which can cause rust and damage to the fuel system.
- Transmission Issues: Transmission problems have also been reported for the 2008 Ford F-650 SD. Some owners have experienced issues with the brake shift interlock switch, which can allow the transmission to be shifted out of park without pressing the brake pedal.
- Electrical System Issues: Electrical system problems have been reported for the 2008 Ford F-650 SD, including issues with the body control module (BCM) software. Certain vehicles manufactured between October 25, 2010, and November 20, 2010, may have been inspected using custom software that did not correctly read the BCM serial number, potentially leading to an internal short.
- Recall History: The 2008 Ford F-650 SD has a history of recalls, with issues related to the engine, transmission, and electrical system. These recalls include problems with the exhaust gas temperature sensor, fuel system, and brake shift interlock switch.
In summary, the 2008 Ford F-650 SD has several common problems related to the engine, transmission, and electrical system. These issues have been documented in recalls and can lead to expensive repairs and safety concerns. Owners are encouraged to stay up-to-date on recalls and address any issues promptly to ensure the safe and reliable operation of their vehicle.
2008 Ford F-650 sd car problems categorized by type of issue
After analyzing all complaints sent to the NHTSA and researching popular Ford F-650 sd problems, we found that the most common problems with these 2023 model year vehicles are:
- Unknown or other problems
- Service brakes problems
- Hydraulic problems
The graph below shows statistics for all 2008 Ford F-650 sd vehicle components and the number of complaints received.
2008 Ford F-650 sd complaints
The NHTSA has received 2 complaints about various vehicle components related to the 2008 Ford F-650 sd.
UNKNOWN OR OTHER PROBLEM
- Date Of Incident: 2019-06-08
- Number Of Injuries: 1
- VIN: 3FRNF65C48V
- Components: UNKNOWN OR OTHER
- Summary: 23-YEAR-OLD SUBJECT WAS A PASSENGER IN A LIMOUSINE/BUS WHICH HAD BEEN BUILT OUT BY LIMOS BY TIFFANY, INC. SHE WAS LOCATED NEAR THE EMERGENCY EXIT WINDOW AREA. EMERGENCY LATCH WAS IN CLOSED POSITION AND WINDOW APPEARED CLOSED; HOWEVER, WHEN DRIVER NEGOTIATED A LEFT CURVE, SUBJECT MADE CONTACT WITH THE WINDOW AND IT OPENED, CAUSING HER TO FALL OUT ONTO THE ROADWAY AND SUSTAIN SERIOUS INJURIES. POST-ACCIDENT TESTING DEMONSTRATED LOCKING HANDLE COULD BE IN THE CLOSED POSITION YET THE WINDOW COULD BE PUSHED OPEN WITH SLIGHT LOADING. THE POSTED SPEED LIMIT AT TIME OF ACCIDENT WAS 55 MPH. *DT*JB *DT*JB
SERVICE BRAKES, HYDRAULIC PROBLEM
- Date Of Incident: 2010-11-07
- VIN: 3FRNF65B88V
- Components: SERVICE BRAKES, HYDRAULIC
- Summary: TL* THE CONTACT OWNS A 2008 FORD F-650. THE CONTACT WAS DRIVING 35 MPH WHEN HE APPLIED THE BRAKES AND THE PEDAL WAS ABNORMALLY DEPRESSED INTO THE FLOORBOARD. THE VEHICLE DID NOT RESPOND AND THE CONTACT HAD TO SHIFT INTO NEUTRAL IN ORDER TO STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHO REPLACED THE MASTER CYLINDER AND CLUTCH SLADE BUT THE BRAKES CONTINUED TO FAIL. THE CONTACT STATED THAT THE CLUTCH SLADE CYLINDER AND MASTER CYLINDER FAILED AND WAS REPAIRED FOUR TIMES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE WHO PROVIDED A PARTIAL REIMBURSEMENT TO THE CONTACT FOR THE COST OF REPAIRS AND A COMPLAINT WAS FILED WITH THE MANUFACTURER. THE FAILURE MILEAGE WAS 80,000 AND THE CURRENT MILEAGE WAS 122,000.
2008 Ford F-650 sd recalls
The National Highway Traffic Safety Administration (NHTSA) has issued 4 recalls for different components of the 2008 Ford F-650 sd.
- Manufacturer: FORD MOTOR COMPANY
- Components: ENGINE AND ENGINE COOLING
- Summary: FORD IS RECALLING CERTAIN MODEL YEAR 2008-2009 F-650 AND F-750 TRUCKS EQUIPPED WITH CATERPILLAR C7 ENGINE. THE #5 AND #6 FUEL LINES MAY CRACK AT THE FASTENING POINT TO THE COMMON FUEL RAIL AND CAUSE A FUEL LEAK.
- Consequence: A FUEL LEAK, IN THE PRESENCE OF AN IGNITION SOURCE, CAN RESULT IN A VEHICLE FIRE.
- Remedy: FORD IS WORKING WITH CATERPILLAR TO NOTIFY OWNERS AND REPAIRS WILL BE PERFORMED BY AUTHORIZED CATERPILLAR DEALERS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 8, 2010. OWNERS MAY CONTACT CATERPILLAR TOLL-FREE AT 1-800-447-4986 OR FORD AT 1-866-436-7332.
- Manufacturer: CUES, INC.
- Components: EQUIPMENT:APPLIANCE:AIR CONDITIONER
- Summary: CUES, INC. IS RECALLING CERTAIN MODEL YEAR 2007-2009 SERVICE VEHICLES BUILT ON VARIOUS CHASSIS EQUIPPED WITH CARRIER AIRV CEILING UNITS, MODEL NOS. 68RV0010BA, 68RV0012CA, AND 68RV0010EA. THE HEATER ELEMENT IN THESE ASSEMBLIES MAY BE DEFECTIVE WHICH COULD CAUSE THE UNIT TO CREATE SMOKE OR SPARKS.
- Consequence: THIS DEFECT COULD RESULT IN A FIRE.
- Remedy: CUES IS WORKING WITH CARRIER TO REMEDY THE AFFECTED VEHICLES. REPAIRS WILL BE MADE BY CARRIER FREE OF CHARGE. PLEASE SEE CARRIER'S DEFECT REPORT 09E-053. THE SAFETY RECALL BEGAN ON JANUARY 5, 2010. OWNERS MAY CONTACT CARRIER AT 1-877-584-7059 OR CUES AT 1-407-849-0190.
- Manufacturer: FORD MOTOR COMPANY
- Components: ENGINE AND ENGINE COOLING:ENGINE:DIESEL
- Summary: FORD IS RECALLING 2,811 MY 2008-2009 F-650 AND F-750 TRUCKS EQUIPPED WITH C7 OR C9 CATERPILLAR DIESEL ENGINES. THE FUEL PUMP OUTLET CHECK PLUG MAY BE CRACKED WHICH COULD CAUSE FUEL TO SPRAY AND LEAK.
- Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
- Remedy: FORD IS WORKING WITH CATERPILLAR (PLEASE SEE 08E042). CATERPILLAR WILL REPLACE THE FUEL PUMP PLUG FREE OF CHARGE. OWNERS MAY CONTACT CATERPILLAR AT 1-800-447-4986, OR FORD AT 1-800-343-5338 (FLEET OWNERS) OR 1-866-906-9811 (MOTOR HOME OWNERS).
- Manufacturer: FORD MOTOR COMPANY
- Components: ENGINE AND ENGINE COOLING:ENGINE:DIESEL
- Summary: ON CERTAIN TRUCKS EQUIPPED WITH CATERPILLAR C7 OR C9 DIESEL ENGINES, A FUEL PUMP FAILURE WILL DILUTE THE ENGINE OIL WITH FUEL AND MAY CAUSE THE TURBOCHARGER TO FAIL AND CAUSE LOSS OF THROTTLE CONTROL WITH WARNING.
- Consequence: THE WARNING MAY BE EXPERIENCED BY ERRATIC PERFORMANCE AND EXCESSIVE SMOKE. BOTH OF THESE CONDITIONS MAY RESULT IN A SITUATION WHERE A VEHICLE CRASH COULD OCCUR.
- Remedy: FORD IS WORKING WITH CATERPILLAR TO HAVE THE FUEL PUMP REPLACED FREE OF CHARGE (PLEASE SEE 07E053). OWNERS MAY CONTACT CATERPILLAR AT 309-675-6496 OR FORD AT 1-800-392-3673.
Additional sources
More sources of information about 2008 Ford F-650 sd problems:
2008 Ford F650SD Cat C7 low power, "Particulate trap soot
Apr 27, 2015 ... Cat et is the only tool that can. The ARD head failing is the most common thing that's causes this problem. I see it all the time.
A/C not blowing cold air | Ford Powerstroke Diesel Forum
Jun 26, 2016 ... Somewhat of a common problem ... yup core is common on these SD's. if they ... A forum community dedicated to Ford F-series owners and enthusiasts ...
Q&A: 2008 Ford F650 Engine Issues - JustAnswer
Mar 28, 2016 ... 2008 Ford F650 Cummins ISB # 46788486. Engine idles fine, has good power, but after driving it under a load for a few - Answered by a ...
04 f650 cat c7 poor performance probs | The Diesel Stop
Jun 25, 2008 ... i took it to the caterpillar dealership for diagnosis. i called them for an update and they said so far no issues were reaching out and grabbing ...
F650 with 6.0 | Ford Powerstroke Diesel Forum
May 12, 2010 ... 2 issues are the EGR and stock head bolts. most people upgrade to ARP studs and delete the egr.
Other years of Ford F-650 sd
Are you having problems with your 2008 Ford F-650 sd?
Leave your review of 2008 Ford F-650 sd